MAINTENANCE SCHEDULE
TASK
DAILY
WEEKLY
YEARLY
Flush tank out with clean water
X
Flush dump pump out with clean water
X
Check/Clean Electronic Float
X
Check/Clean Ball Floats at Vacuum Inlets in Recovery Tank
X
*Check Carbon Brushes
X
*Have a US Products service technician check the vacuum motor brushes once a year or after 300 operating hours.
GENERAL TROUBLESHOOTING
IF THIS
CHECK THIS
Pump or Vac Does Not Turn On
Check the circuit breakers in the wall. If both cords were on one circuit the breaker may
have tripped.
The switches should light up when turned ON. Check the switch to make sure it is
working.
Dump Pump Not Discharging
Check the circuit breakers in the wall. If both cords were on one circuit the breaker may
have tripped.
The switches should light up when turned ON. Check the switch to make sure it is
working.
Check electronic
fl
oat to make sure it is not obstructed and moving freely.
Pump Pressure is Low
Check the spray tip(s) for proper size or excessive wear.
The pressure relief valve may be stuck open, or the seat may be worn.
Check the inlet
fi
lters for dirt or debris.
The pump inlet or outlet valves may be dirty or damaged.
Vacuum Suction is Low
Make sure the tank lid is closed tightly, the drain hose is closed tightly, and the recovery
hose is tight at the vac inlet hose barb and at the tool.
Check the hose for cracks.
Water Leaking from Pump
Worn packing in pump.
Oil Leaking from Pump
Worn piston seals.
Misaligned oil seal O-Ring.
Bad bearing.
Damaged crankcase.
TECHNICAL SPECIFICATIONS (as installed and tested on the unit)
MODEL
TORRENT
56380561
POWER CORD:
Two, 25 ft, 12 gauge, 3-wire with hospital grade
plug
Two, 25 ft, 12 gauge, 3-wire with hospital grade plug
POWER CONSUMPTION:
15 Amps, each cord
15 Amps, each cord
RECOVERY CAPACITY:
9 gallon
9 gallon
VACUUM INTAKE HOSE:
1.5” inch X 25 ft
1.5” inch X 25 ft
VACUUM MOTOR(s):
Two, 3-stage
Two, 3-stage
WATER LIFT/CFM:
100 inches / 170 cfm
100 inches / 170 cfm
AIR WATTS:
520 AW in operational range
520 AW in operational range
OVERFLOW PROTECTION:
Electronic
fl
oat; auto off/on
Electronic
fl
oat; auto off/on
HIGH PRESSURE PUMP
Triplex Plunger Pump, Adjustable 1200-400 psi
working pressure,
Triplex Plunger Pump, Adjustable 1200-400 psi
working pressure,
DISCHARGE PUMPS:
One diaphragm bilge pumps
One diaphragm bilge pumps
DISCHARGE HOSE:
One 3/4 inch X 50 ft
One 3/4 inch X 50 ft
DISCHARGE RATE:
5.2 GPM
5.2 GPM
FILTER SYSTEM:
One 80 micron mesh strainer at water inlet on
recovery tank; One 60 mesh S/S
fi
lters in the
recovery tank
One 80 micron mesh strainer at water inlet on
recovery tank; One 60 mesh S/S
fi
lters in the
recovery tank
WEIGHT
145 LBS
145 LBS
revised 1/12
1/12
A - 9
56041839 - TORRENT
ENGLISH - A
INSTRUCTIONS FOR USE
