Page 30
Huskey C-425 Sevcon DC System Operator Manual
MC-425-12
Battery Disconnect Switch
This vehicle is equipped with an Battery Disconnect Switch. The Battery Disconnect Switch should
be used if the vehicle starts to operate in an unexpected manner or if there is an odor or sound
that may indicate an overloaded electrical circuit. If any of the above occurs, immediately and
safely pull to the side of the road and stop. Then push on the switch knob and exit the vehicle.
Do not reengage the switch until the vehicle has been inspected by a qualified technician.
The Battery Disconnect Switch should only be activated if the vehicle must be immediately
stopped. Do not use the switch when only parking the vehicle.
Stopping
Release the throttle pedal and use your right foot to press the brake pedal. The amount of force
required to stop the vehicle will vary depending on the environment and load on the vehicle.
Unless in an emergency, do not turn the start witch OFF until the vehicle has come to a complete
stop.
This vehicle is equipped with regenerative (regen) braking. Regen braking uses the stored energy
of the moving vehicle to generate electricity. The generation of electricity slows the vehicle down
and the power generated is put back into the batteries increasing the driving time of your vehicle.
There is more than one regenerative braking mode. The mode used depends on the current
driving conditions as follows:
•
While Coasting:
When you release the throttle pedal, the Neutral Regen mode is
selected and gradually slows the vehicle. Only a small amount of
power is generated.
•
Changing Direction: The Direction Regen mode is selected when the direction of the
vehicle is changed while the vehicle is in motion. In this mode the
motor is reversed and slows the vehicle to a stop and then continues
in the opposite direction.
Parking
1. Bring the vehicle to a stop at an authorized parking space.
2. Place the Direction Control switch in the center OFF position.
3. Turn the start switch OFF.
4. Firmly set the parking brake.
5. Remove the key from the Start switch. The driver should keep the key in his/her possession.
Note: If parking this vehicle on an incline, turn the wheels to the curb, or block the wheels.
Brakes contaminated with water or mud may not work properly until dried out.
ALWAYS test brake operation immediately after driving through puddles or mud. Failure
to test brake operation may result in the inability to stop in an emergency causing in
severe personal injury and/or property damage.
WARNING
