932208 Rev. A
X I I . S u n r i s e L i m i t e d W a r r a n t y
49
X I . M a i n t e n a n c e
932208 Rev. A
48
1. LIMITED WARRANTY
Sunrise Medical warrants components of this wheelchair against defects in materials
and workmanship from the original date of purchase from Sunrise Medical as follows:
a. Lifetime: main frame
b. Five (5) years: the Perfect Fit seat frame, interface bracket,
and structural components
c. Two (2) years: motors, gearboxes, joystick, the main controller,
tilt, lift, recline motors and any actuators
d. One (1) year: all other original components except; wheels,
upholstery, plastic or rubber parts and painted surfaces.
e. Three (3) months: wheels, upholstery, plastic or rubber parts
and painted surfaces
2. LIMITATIONS
a. We do not warrant damage due to:
•Neglect, misuse, or improper installation or repair.
•Use of parts or changes not authorized by Sunrise.
•Exceeding the weight limit of 300 lbs (or 400 lbs with heavy duty package).
b. This warranty is void if the original chair serial number tag is removed or altered.
c. This warranty applies in the USA only. Check with your supplier to find out if
international warranties apply.
3. WHAT WE WILL DO
Our sole liability is to repair or replace covered parts.
This is your only remedy for consequential damages.
4. WHAT YOU MUST DO
a. Return the warranty card.
b. Obtain from us, while this warranty is in effect, prior approval for return or
repair covered parts.
c. Return the wheelchair or part(s), freight pre-paid, to Sunrise Mobility Products
Division at: 2842 Business Park Ave., Fresno, CA 93727-1328.
d. Pay the cost of labor to install or repair parts.
5. NOTICE TO CONSUMER
There are no other express warranties. To the extent permitted by law, any implied warranty
(including a warranty of merchantability or fitness for a particular purpose) is limited to:
a. One (1) year from the first consumer purchase, and
b. Repair or replacement of the defective part only.
This warranty gives you certain legal rights. You may also have other rights that vary
from state to state.
2. 14" Drive Wheels:
a. Elevate and securely support chair so that wheel
is off the ground. Release all air from tire.
b. Remove four (4) lug nuts (A) from rim using a
socket wrench.
c. Make sure all air has been removed from tire.
Remove the four bolts inside the rim. Separate
two halves of rim (B).
d. Repair or replace inner tube. Reassemble the
wheel. Use a torque setting of 120 in.-lbs. (13.5
N.m) to re-tighten bolts.
e. Inflate tire to proper pressure level (listed on
tire sidewall).
G. ORDERING PARTS
When you order parts, provide the following:
1. Model of chair
2. Serial number of chair
3. Left hand or right hand control
4. Part number, description and quantity of parts
you need.
5. State reason for replacement.
H. MAINTENANCE CHART
You should check the items on this chart at the indicat-
ed intervals. If any of the items are loose, worn, bent
or distorted, immediately have them checked and/or
repaired by your authorized Sunrise supplier. Frequent
maintenance and servicing will improve performance,
extend wheelchair life, and help prevent injuries.
Charge Batteries
3
Check tires for proper inflation level
3
Check batteries for proper electrolyte level (wet only)
3
Check plugs and connectors for proper connections
3
Check all moving parts for wear
3
Inspect all nuts, bolts and fasteners for looseness or wear
3
Inspect upholstery for wear
3
Service by authorized supplier
3
Ann
ually
Qu
arterly
Mon
thly
W
eekly
Daily
CHECK...
14" drive wheel
A
B
