●
Breaking in
During the first 25 hours of operation running-in), the following precautions should be used;
-
Avoid travel at high speeds
-
Change speed often so that the parts will break in uniformly and in a shorter time
-
Avoid turning the throttle more that 3/4 of the way.
Warning:
·
Change the crankcase oil after 500km.
·
Always use a mixture of green grade gas and a qualitatively good oil.
·
After the first off-road use, check all of the nuts and bolts.
●
Startup
Manual hand pull
-Open fuel tank valve
A
ON
= open
-Sharply pull on the starter as shown in the figure
while slightly turning the throttle twist grip.
-Always close the fuel tank valve when the engine is off.
Note:
With the engine cold, act on the starter by pushing
up
lever
B
, start the engine and wait for a short, then
reposition the lever to its former position.
●
AIR FILTER
Air filter
A
is located under the rear shock absorber,
and is directly connected to the carburetor by rubber
manifold
B
.
To remove the filter, loosen clamp screw
C
, then pull
out the filter and clean it.
Note:
If the filter is very dirty, first wash it with petrol
and then with water and soap.
Clean the filter every time the vehicle is used in
cross country.
