10
Owner’s Manual:
05995
1784779 Rev Y
ECO 18-0034
July 2018
www.radiaproducts.com (PHONE) 800-221-1083 | (INTL) +1-763-533-2969 | (FAX) 763-533-0015
1.
Open the cabinet door and load the
container(s) as illustrated in either section
4.2, Install a Single Pail, or 4.3, Install multiple
containers.
2.
Turn the power switch to ON.
3.
Be sure the emergency stop button is in
the ON position.
4.
Press the desired timer button.
5.
Verify that the MIXING light comes on
while the upper clamp lowers and secures
the pail(s). The machine will mix for the
amount of time set on the timer.
6.
Open the door when the cycle is complete,
the MIXING light is off, and the upper clamp
raises.
i.
Stop the cycle early, if desired, by
pushing either the E-STOP button, or the
RAISE CLAMP button.
ii.
Press the RAISE CLAMP button once to
retract the upper clamp further, or hold it
for two seconds to retract the clamp to its
home position.
7.
Remove the pail(s) of mixed paint.
Do not load containers of different heights
into the mixer. Shorter containers will come
loose during use and damage the shaker
and containers.
The machine can mix up to four one-
gallon
OR
four one-pint containers at a
time. Four four-liter containers will not fit.
1.
Arrange the containers as close as
possible to each other and in the
center
of
the lower clamp plate
(A)
.
2.
Close the door and start the machine.
(A)
If there is excessive noise or pail shuffling
during the mix cycle, determine if the
wood disk or pad should be used with the
pail type being mixed.
Because pails can be dimensionally
different from each manufacturer, the pad
or wooden disk may not be required.
Please make note of what pails require the
use of the pad and wood disk along, with
those that do not.
Never mix damaged metal
cans
.
Always inspect each can prior to mixing
for any dents along the bottom ridge and
side walls. Mixing a container with dents
can cause the clamp to release, or crush
a container during a mix cycle.
4.4 Run a Mix Cycle
..Operation, Continued
4.3 Install Small, Containers
