5-6
8. Check the fuel filters for the presence of water, as
shown in the Periodic Maintenance section.
9. Clean the throttle and governor linkage. Protect
them by wrapping with a clean cloth.
10. Clean and wipe the entire unit. Coat parts suscepti-
ble to rust with a light coat of oil or grease.
11. Provide a suitable cover for the entire unit after it
cools down.
RETURNING THE SET TO OPERATION
1. Remove the protective cover from the unit. Wipe off
dust and dirt.
2. Check that fuel lines and injectors are secure and
properly torqued without air or fuel leaks.
3. Check the tag stating the oil type and weight. If it is
not correct, drain oil from the engine, and refill with
the correct oil. Be sure that it is up to “FULL” mark
on dipstick.
4. Remove the material used to plug the exhaust outlet
and reconnect the exhaust line. Check the com-
plete exhaust system for tight connections. Note
the condition of the muffler, exhaust line, etc., and
repair as necessary.
Exhaust gases contain carbon
monoxide, which may cause severe personal in-
jury or death. Before operating the generator
set, make certain the exhaust line is connected
correctly, is fit for operation, and does not leak.
5. Check the entire generator set for fuel or oil leaks.
Correct as required.
6. Check the wiring system for worn wires, loose con-
nections, etc. Repair as required.
7. Install the fully-charged batteries, and connect them
to the generator set. Observe correct polarity. Con-
nect the ground cable last.
Explosive gases are emitted from
batteries when they are being charged. Ignition
of these gases can cause severe personal in-
jury. Do not smoke or allow flame, sparks or arc-
ing equipment in the vicinity while servicing
batteries.
8. Verify that no loads are connected to the generator.
9. Start the engine, and observe the oil pressure
gauge and charge rate ammeter. After start, apply
load to at least 50 percent of rated capacity.
After the engine has started, excessive blue smoke
will be exhausted until the rust inhibitor or oil has
burned away.
