Napoleon HYBRID 100, Инструкция по установке и эксплуатации, Страница: 2 / 88

W415-1066 / C / 06.22.12
2
TABLE OF CONTENTS
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
1.0 INsTALLATION OvERvIEw 3
2.0 INTRODUCTION 4
2.1 dimensions 5
2.2 general instruCtions 5
2.3 general information 7
2.3.1 features 7
2.3.2 heating speCifiCations 7
2.3.3 eleCtriCal speCifiCations 7
2.3.4 optional modules 7
2.3.5 appliCable standards 7
2.3.6 California prop65 7
2.4 rating plate information 7
3.0 INsTALLATION pLANNINg 8
3.1 loCation and ClearanCes 8
3.2 outside Combustion air 8
4.0 INsTALLATION 11
4.1 Crated unit Contains 11
4.2 reCommended step 11
4.3 removal of furnaCe from base of skid 12
4.4 loCating return air filter 13
4.5 eleCtriCal loCations and ConneCtions 14
4.5.1 supply lines 14
4.5.2 thermostat Wiring 16
4.5.3 thermostat loCation 16
4.5.4 installing the fan/limit sWitCh 17
4.5.5 seCuring Wire harnesses 20
4.6 seCondary air tubes / baffles installation 20
4.7 door handle installation 21
4.8 optional eleCtriC baCk up furnaCe 21
5.0 CLEARANCE TO COMBUsTIBLE MATERIALs/ pLENUM AND vENTINg INsTALLATION 25
5.1 flue / Chimney 25
5.1.1 Controlling draft 25
5.1.2 measuring draft 25
5.2 minimum ClearanCe to Combustibles 26
5.3 general plenum and duCting - ClearanCe to Combustibles 26
5.3.1 minimum Ceiling height requirements 26
5.3.2 installation With return/supply plenums and Complete duCt system 26
5.3.3 installation With the hmfk-dp diffusion plenum 27
5.4 ember stop 28
6.0 gENERAL OpERATINg INsTRUCTIONs 29
6.1 draft Control 29
6.2 poWer out operation 30
6.3 Control system - seCondary furnaCe "Wood/eleCtriC" Configuration 30
6.4 Control system - summer fan 31
6.5 operating sounds and smells 31
6.6 starting a fire 31
6.7 fuel loading and burn CyCle 33
6.8 re-loading the applianCe 33
6.9 flash fires 34
6.10 ash removal proCedures 34
6.11 inspeCtion of flues and Chimneys 35
7.0 MAINTENANCE 36
7.1 run-aWay or Chimney fire 36
7.2 Creosote formation and removal 36
7.2.1 Chimney maintenanCe 36
7.3 fire eXtinguishers and smoke deteCtors 37
7.4 seleCting Wood 37
7.5 glass and gasket replaCement 37
7.6 firebriCks and baffles 38
7.7 glass replaCement 38
7.8 filters 39
7.9 bloWer motor lubriCation 39
7.10 Care of glass (if equipped) 39
8.0 REpLACEMENTs 40
9.0 TROUBLE sHOOTINg gUIDE 41
10.0 wARRANTY 42
11.0 sERvICE HIsTORY 43
12.0 NOTEs 44