Mash 125cc X-RIDE, Руководство пользователя

Страница: 13 / 27

24 25
1
2
Back to summary
Engine oil
Replacing the engine oil.
Engine oil plays an important role in the normal operation of the engine and for
this reason it is necessary to check the engine oil periodically and to renew it after the
first 1000 km and then every 5000 km according to the procedures. following.
Note : When draining, clean the gauge (if equipped) and replace the oil filter.
Engine oil change
Replacing the engine oil should be done while the engine is still warm to allow the
fluid to drain completely.
To do this, proceed as follows:
1. Immobilize the motorcycle by placing it in a vertical position
2. Remove the oil filler cap
3. Unscrew the drain screw and let out the used oil
4. Replace the oil filter
Caution
Check carefully for leaks around the oil filter cover.
5. Tighten the drain screw and fill with new oil
The total engine oil capacity is 950mL (engine dismantling)
Drain screw tightening torque: 20-30 Nm
6. Check the oil level using the gauge (if equipped) or the oil level sight glass.
Checking the oil level
Before each use of the vehicle, always check the oil level with the gauge or the oil
level sight glass to make sure that the amount of oil is correct.
Caution
The use of inferior quality oil can permanently damage the engine and
seriously shorten its life.
Pre-ride inspection
Before road, remember to check the following points. Never underestimate the
importance of inspection.
Element Control to be carried out
Handlebar Ensure that direction is:
- soft
- free
- no hard point in rotation
Lighting Operate all lights (front light, rear light, front and rear brake light,
instrument cluster lighting, turn signals)
Engine oil Check the oil level
Coolant
Caution
This engine has a liquid cooling system. During the operation of the
motorcycle, the coolant is at high temperature and high pressure in the cooling
system. Therefore, it is strictly forbidden to open the radiator cap in this condition,
in order to prevent and avoid burns.
The coolant must be added in time and in sufficient quantity to avoid damage
to the engine.
Coolant should be added after the engine has stopped and cooled down.
Antifreeze belongs to the chemicals, which include toxic substances. If the
antifreeze gets into the eyes or on the skin, wash immediately with plenty of
water.
Coolant tank
On the right side of the front end of the
vehicle’s fuel tank is equipped with a coolant
make-up tank ① and the radiator cap ②.
The coolant top-up tank ① is equipped with
level graduations in the tank, the level should
be between upper and lower graduations.
When the water level is below the minimum
limit, open the radiator cap ②, add special
antifreeze to the makeup tank, do not add tap
water or other liquid