4
1.0
INTRODUCTION
•
The Lochinvar Mini Copper-Fin range is a floor standing direct gas fired water heater or boiler. The
equipment comprises a copper finned tube heat exchanger surrounded with a high density, light weight
refractory insulation. A durable outer steel jacket assembly provides structural integrity and easy
disassembly. The gas train includes black iron inlet manifold(s) and stainless steel atmospheric burner
assemblies.
•
The burners are initiated by a full ignition sequence control that incorporates an intermittent pilot
assembly and rectification supervision of the flame.
•
For the correct operation of the appliance when used as a water heater, it is essential that a suitably
sized, glanded-construction bronze pump is utilised to maintain a constant water flow rate through the
heat exchanger. When used as a water heater, the Mini Copper-Fin should also be used in conjunction
with an appropriately sized storage vessel (available from Lochinvar Limited as an ancillary option).
•
This equipment is intended for use on Group H Natural Gas (2
nd
Family) and LPG propane (3
rd
Family).
The information relating to propane firing is to be found in Section 13: LPG FUEL. This equipment
MUST NOT use gas other than that for which it has been designed and adjusted.
•
This equipment must be installed by a competent person, registered with a H.S.E. approved body. All
installations must conform to the relevant Gas Safety and Building Regulations. Health & Safety
requirements must also be taken into account when installing any equipment. Failure to comply with the
above may lead to prosecution.
•
If the equipment is to be connected to an unvented (pressurised) system, care must be taken to ensure
all extra safety requirements are satisfied should a high or low-pressure condition occur in the system.
•
The equipment is designed for direct connection to a flue system via the draught diverter built in to the
equipment casing. The flue outlets from more than one unit may be connected to a single chimney.
•
Ancillary Options:
•
Primary Circulating Pump (MCW91-361CE)
Omega 4-60-2ZS
•
Primary Circulating Pump (MCW401-501CE)
Omega 4-90-2ZS
•
Direct Storage Cylinder (297 litre)
LST66
•
Direct Storage Cylinder (450 litre)
LST100
•
Direct Storage Cylinder (747 litre)
LST166
•
Direct Storage Cylinder (1155 litre)
LST250
•
Unvented/Boosted Water System Kits
Contact Lochinvar Limited
•
De-stratification Pump Kit
WH9
•
Pre-Fabricated Interconnecting Pipework
Contact Lochinvar Limited
•
Stacking Frame (MCW/MCB91-181CE)
MSF3050
•
Stacking Frame (MCW/MCB226-361CE)
MSF3051
•
Stacking Frame (MCW/MCB401-501CE)
MSF3052
•
Stacking Frame (MCW + Storage)
Contact Lochinvar Limited
