KisanKraft
TM
KNAPSACK BATTERY SPRAYER
KK-KBS-165/167/169/183/185/187/189
KNAPSACK MANUAL CUM BATTERY SPRAYER
KK-KMB-4184
: www.kisankraft.com
: +91.80. 22178200
Page 19 of 24
MAINTENANCE AND STORAGE
Daily maintenance:
The following maintenance should be done after daily job.
1. Cleaning the oil and dust on the surface of the machine.
2. Clean the chemical tank with clean water and wipe it dry.
3. Check if there is any leakage of water or fuel. If there is a leakage, remedy procedures
are to be taken.
4. Check to see if the screws are loose or lost. If so, please tighten the screw or replace.
5. The battery must be charged before storage. Charge before every use in case of power
shortage.
6. The machine after maintenance should be stored in a place which is dry and has good
ventilation. It must be far away from any fire source and sunlight.
Long term Storage:
The machine which is to be stored t for a long time should be maintained as follows:
1. Clean the machine surface carefully.
2. Discard any medicine in the tank and the pump, clean them with clean water.
3. The battery must be charged before storage. If stored for a long time, it should be
charged every two months.
4. All the plastic parts must neither be exposed to the sunlight nor pressed by heavy
matter.
5. Cover the machine with plastic dustcoat and store in a dry and clean place.
a) Cleaning
1. Clean chemical container
Discard remaining chemical liquid and wash it thoroughly. Fill one liter
of water into the chemical tank and then rinse it slightly.
2. Clean the inside liquid pump
After cleaning the chemical tank, fill with clean water again and start
liquid pump to mist so as to clean the whole pipeline.
3. Clean the filter net
a) Clean the filter net in the mouth of the chemical tank.
b) Clean the filter net of suction inside the chemical tank.
There is a filter net of suction at the bottom of the chemical tank to
avoid the dust coming from the filter net of the mouth of the
chemical tank to be sucked into the liquid pump. The filter of the
suction is jammed to spray abnormally and will infect the liquid
pump greatly. So please take out the filter of suction to clean
carefully after operating. Fix it carefully after cleaning.
Don’t allow
the remaining chemical liquids and the water used for washing the machine flow
into rivers, lakes, ponds or cloacae in order avoid pollution.Please deal with it innoxiously
b) Maintenance of the battery:
In the course of operation, one should understand the frequency and duration of charge
according to the actual condition and referring to usual spr
ay frequency and time. It’s better
to charge when the battery discharged to 60%--70%, the average charging time is about 8
hours. Longer charging time may cause the battery to lose water, hot and reduce the life.
Never stock the battery without power. If it happens so and you
couldn’t recharge the battery
on time, it will easily get vitriolized to lead sulphate crystal
，
which jams the path of the
electrical ions, and make the power insufficient. Also the capacity of the battery will get
reduced. If the battery is without power for a long time, serious damage will be caused.