SAMPLE
FORM #: 09-NMAX5100
PAGE 2 OF 6 09-WMB-GN (10/09)
COVERAGE UNDER THE PLAN: WHAT IS
COVERED?
The plan will pay the total cost (parts and
labor) less a deductible per visit, to correct any of the
following mechanical failures, caused by a defect in materials
or workmanship of a covered component and are not
covered by the vehicle’s factory warranty. The only
exceptions are those listed under “What is not covered by
the Plan”.
This plan offers comprehensive mechanical
coverage for your vehicle. COMPONENTS
COVERED BY THE PLAN INCLUDE (BUT ARE NOT
LIMITED TO):
GASOLINE ENGINE:
Cylinder Block and all Internal
Parts; Cylinder Head Assemblies; Timing Case, Timing
Chain, Timing Belt, Gears and Sprockets; Harmonic
Balancer; Oil Pump; Water Pump and Housing; Intake and
Exhaust Manifolds; Flywheel with Starter Ring Gear; Core
Plugs; Valve Covers; Oil Pan; Turbocharger Housing and
Internal Parts; Turbocharger Wastegate Actuator;
Supercharger; Fuel Injectors (excluding clogged injectors);
Serpentine Belt Tensioner; Seals and Gaskets.
DIESEL ENGINE (CHRYSLER VEHICLES ONLY):
Cylinder Block and all Internal Parts; Cylinder Head
Assemblies; Timing Gears and Cover; Harmonic Balancer;
Oil Pump; Water Pump and Housing; Intake and Exhaust
Manifolds; Core Plugs; Valve Covers; Oil Pan; Turbocharger
Housing and Internal Parts; Fuel Injection Pump and
Injectors; Seals and Gaskets.
TRANSMISSION:
Transmission Case and all Internal
Parts; Torque Converter; Drive/Flex Plate; Transmission
Range Switch; Transmission Control Module; Bell Housing;
Oil Pan; Seals and Gaskets.
NOTE: MANUAL TRANSMISSION CLUTCH PARTS ARE
NOT COVERED AT ANY TIME.
FRONT WHEEL DRIVE:
Transaxle Case and all Internal
Parts; Axle Shaft Assemblies; Constant Velocity Joints and
Boots; Front Wheel Bearings; Differential Cover; Oil Pan;
Transaxle Speed Sensors; Transaxle Solenoid Assembly;
PRNDL Position Switch; Transaxle Electronic Controller;
Torque Converter; Seals and Gaskets.
NOTE: MANUAL TRANSMISSION CLUTCH PARTS ARE
NOT COVERED AT ANY TIME.
REAR WHEEL DRIVE:
Rear Axle Housing and all Internal
Parts; Axle Shafts; Axle Shaft Bearings; Drive Shaft
Assemblies; Drive Shaft Center Bearings; Universal Joints
and Yokes; Seals and Gaskets.
FOUR-WHEEL DRIVE (4x4):
Transfer Case and all
Internal Parts; Axle Housing and all Internal Parts; Axle
Shafts; Axle Shaft Bearings; Drive Shafts Assemblies (Front
and Rear); Drive Shaft Center Bearings; Universal Joints and
Yokes; Disconnect Housing Assembly; Seals and Gaskets.
ALL-WHEEL DRIVE (AWD):
Power Transfer Unit and all
Internal Parts; Viscous Coupler; Rear Driveline Module;
Front and Rear Axle Housing and all Internal Parts; Constant
Velocity Joints and Boots; Drive Shaft and Axle Shaft
Assemblies; Differential Carrier Assembly and all Internal
Parts; Output Ball Bearing; Output Flange; End Cover;
Overrunning Clutch; Vacuum Motor; Torque Tube; Pinion
Spacer and Shim, Seals and Gaskets.
STEERING:
Steering Gear Housing and all Internal Parts;
Power Steering Gear; Power Steering Pump; Steering Shaft
Lower Coupling; Rack and Pinion Assembly; Seals and
Gaskets.
AIR CONDITIONING:
Factory or Manufacturer-authorized
air conditioning installations only. Air Conditioning
Compressor, Clutch, Coil, Condenser, Evaporator, Receiver-
Drier, Expansion Valve, Hoses and Lines, Low Pressure Cut-
Off Switch, High Pressure Cut-off Switch, Clutch Cycling
Switch, Instrument Panel Control Assembly, Power Module,
Air Conditioning/Heater Blower Motor; Seals and Gaskets.
ENGINE COOLING & FUEL:
Cooling Fan, Clutch and
Motor; Radiator; Coolant Temperature Switch; Fuel Pump;
Water Pump and Housing; Fuel Tank Sending Unit; Fuel
Tank and Lines; Serpentine Belt Tensioner; Seals and
Gaskets.
FRONT SUSPENSION:
Struts; Strut Mounting Plates,
Bushings and Bearings; Upper and Lower Control Arms;
Control Arm Shafts; Control Arm Bushings; Upper and Lower
Ball Joints; Front Wheel Bearings.
REAR SUSPENSION:
Rear Leaf Springs; Rear Coil
Springs; Auxiliary Springs; Spring Interliner; Spring Bushing;
Spring Shackle; U-Bolt Rear Spring; Spring Hanger; Axle
Trac Bar; Lateral Link Arm; Shock Mount Plate; Rear Trailing
Arm Assembly; Stabilizer/Sway Bar; Stabilizer/Sway Bar
Link; Stabilizer/Sway Bar Bushing;
ELECTRICAL:
Starter Motor and Solenoid; Generator
(Alternator); Engine Control Module - (Single Module Engine
Controller) (SMEC); Powertrain Control Module; Distributor;
Ignition Coil; Coil Pack Assembly; Voltage Regulator; Horn
and Horn Pad; Transmission Control Module.
EXPANDED ELECTRICAL:
All Wiring Harnesses;
Electronic Fuel Injection System (excluding clogged
injectors); Windshield Wiper Motor; Rear Window Wiper
Motor; Wiper Control Module; Manually Operated Electrical
Switches; Park Neutral Position Switch; Temperature
Sending Unit/Switch; Oil Pressure Sending Unit/Switch; Body
Computer; Body Control Module. Factory Installed Radio and
Speakers (Includes CD and Tape Player).
POWER GROUP:
Rear Window Defroster; Power Window
Motors; Power Window Flex Track; Power Antenna; Power
Seat Motors; Power Door Locks and Linkage.
LUXURY GROUP:
Keyless Entry Receiver/Module; Trip
Computer; Message Center; Overhead Electronic Vehicle
Information Center; Overhead Electronic Compass/
Temperature; Power Sunroof Motor; Convertible Top Motor;
Electric Mirror Motor and Controls; Cruise Control Servo;
Headlight Door Motor; Concealed Headlamp Module.
NOTE: ANY REMOTE TRANSMITTER IS NOT COVERED
AT ANY TIME.
MOPAR ACCESSORIES:
The following Mopar
accessories are covered provided they were installed by a
Chrysler authorized facility; Audio Systems (including
Compact Disc and Cassette Players); Rear Seat Video
System; Air Conditioning Systems; Speed Control; EVS
(Security Systems); Clocks; Remote Trunk Release; Power
Steering; Remote Control Outside Mirrors; Power Sliding
Rear Windows (trucks); Transmission Oil Cooler.
INSTRUMENTATION:
Electronic Instrument Cluster;
Amp/Voltmeter Gauge; Fuel Gauge; Temperature Gauge;
Tachometer; Oil Pressure Gauge; Turbo Gauge;
Speedometer.
BRAKES:
Master Cylinder; Assist Booster; Wheel
Cylinders; Disc Brake Calipers and Pistons; Brake Lines,
Hoses, Fittings; Proportioning Valve; Seals and Gaskets.
NOTE: BRAKE SHOES, PADS, ROTORS, AND DRUMS
ARE NOT COVERED AT ANY TIME.
ANTI-LOCK BRAKES (ABS):
Brake System’s Hydraulic
Assembly; Pump Motor Assembly; Controller; Sensors and
Relays; Seals and Gaskets.
____
X
X
X
X
____
X
X
X
X
