J. A. Roby MAGNUM Скачать руководство пользователя страница 2

Страница: 2 / 29

November 5, 2015

TABLE OF CONTENT

Introduction ............................................................................... 3

Warning .................................................................................... 3

Rating plate .............................................................................. 4

Appliance Dimension ................................................................ 5

Specifications ........................................................................... 5

Clearances to combustible material ......................................... 5

Installation ................................................................................ 6

Floor protection .................................................................... 6

Floor protection plate minimum dimensions .................... 6

Clearances of the stove until the floor plate protection .... 6

Minimums clearances to combustible material ..................... 7

Assembly before installation ................................................ 8

Installing legs ................................................................... 8

Fan and Snap disc box installation .................................. 8

Firebricks installation............................................................ 9

Bottom firebricks installation ............................................ 9

Back firebricks installation ............................................... 9

Side firebricks installation .............................................. 10

Firebricks installation on the pipes ................................. 10

General stove installation steps ......................................... 12

Chimney connector installation .......................................... 13

General steps of chimney installation ................................ 14

Inside Masonry Chimney, Vertical Installation ............... 15

Outside Vertical Installation ........................................... 15

Cathedral Vertical Installation ........................................ 15

Offset Installation ........................................................... 16

Vertical Installation......................................................... 17

External combustion air source .............................................. 18

Air Inlet Obstruction ....................................................... 18

Stainless steel deflector replacement................................. 19

Front deflector replacement ........................................... 19

Stainless steel tubes replacement ..................................... 19

Stainless steel tube Installation ..................................... 19

Tube support installation .................................................... 20

Operating Instructions ............................................................ 21

Primary and secondary air admission control .................... 21

Lightning fire ...................................................................... 21

First fire .............................................................................. 21

Keep a fire ......................................................................... 21

Fans Controls .................................................................... 22

Wood storage .................................................................... 22

Maintenance ........................................................................... 23

Ash Removal ..................................................................... 23

Ash Disposal ...................................................................... 23

Creosote Formation ........................................................... 23

Chimney Inspection ........................................................... 23

Chimney Sweeping ............................................................ 23

Door care ........................................................................... 24

Air Tighten Adjustment ....................................................... 24

Door adjustment (hinges side) ....................................... 24

Door adjustment (right side) .......................................... 24

Cleaning up glass .......................................................... 24

Disassembly and reassembly of door ............................ 24

Replacing broken glass ................................................. 24

Replacing glass fiber rope ............................................. 25

Glass fiber rope preparation .......................................... 25

Glass fiber rope installation ........................................... 25

What to do in case of Chimney Fire ....................................... 25

Appendix 1 ............................................................................. 26

Door assembly ................................................................... 26

Square Door .................................................................. 26

Appendix 2 ............................................................................. 27

Circuit diagram of fan ......................................................... 27

Snap Disc Box parts description ........................................ 27

Appendix 3 ............................................................................. 28

Parts that can be replaced ................................................. 28

J. A. ROBY LIMITED LIFETIME WARRANTY ....................... 29

Содержание MAGNUM






























Результаты поиска

Содержание MAGNUM

Отзывы:

Похожие инструкции для MAGNUM

Бренды по названию

Популярные бренды

J. A. Roby MAGNUM, Инструкция по эксплуатации

Результаты поиска

Содержание MAGNUM

Отзывы:

Похожие инструкции для MAGNUM

Бренды по названию

Популярные бренды