31
RU
Инструкция по эксплуатации
компрессора при температуре свыше 10°C, SAE10,
- ниже 10°C.
ВНИМАНИЕ!
Запрещается
использовать
компрессор
без
масла или при его недостаточном
количестве, поскольку это может
привести к поломке и аннулирует
право на гарантийный ремонт.
ПРЕДУПРЕЖДЕНИЕ! ВНИМАНИЕ!
Если необходимость дозаправки
возникает в процессе работы,
сначала необходимо выключить
компрессор и отключить его от
источника питания.
ВКЛЮЧЕНИЕ / ВЫКЛЮЧЕНИЕ
Включение
∙
Подключите компрессор к источнику питания.
∙
Переведите выключатель (10) вверх.
Выключение
∙
Переведите выключатель (10) вниз.
∙
Извлеките штепсель из розетки.
ОСТОРОЖНО!
Никогда
не
отключайте шнур питания для
остановки устройства! Вместо
этого переведите двухпозиционный
переключатель (10) в положение
ВЫКЛ. (OFF)!
ИНСТРУКЦИЯ ПО ЭКСПЛУАТАЦИИ
∙
Установите компрессор на сухую твердую
ровную поверхность, чтобы обеспечить надлежащее
смазывание элементов.
∙
Берегите компрессор от воды.
∙
Рабочий
участок
должен
хорошо
проветриваться.
∙
Для транспортировки компрессора сначала
отключите его, отсоедините от источника питания
и спустите давление с цилиндра (2), после чего
компрессор можно перемещать.
∙
Если компрессор не используется, отключите
его, извлеките штепсель из розетки и спустите воздух
с цилиндра (2) и подсоединенных инструментов.
Автоматическое реле давления (9)
Автоматическое реле давления (9) позволяет
поддерживать в цилиндре (2) постоянное давление,
включает
или
отключает
электродвигатель
компрессора в зависимости от степени потребления
сжатого воздуха подсоединенными устройствами.
При включении компрессор начинает закачивать
воздух в цилиндр (2) через специальный
соединитель (12).
По достижении максимального давления (значение
этого параметра устанавливается на заводе при
прогоне компрессора) срабатывает реле давления
(9) и двигатель останавливается.
Избыточное количество воздуха в соединителе
(12) и компрессорном насосе (15) спускается
через невозвратный клапан (26), таким образом,
в компрессорном насосе (15) и соединителе
отсутствует избыточное давление (12). Невозвратный
клапан (26) предотвращает обратный поток воздуха
из цилиндра (2) к верхней части компрессора. При
этом сокращается нагрузка на электродвигатель при
следующем запуске компрессора.
Когда давление падает до минимума, включается
электродвигатель
и
компрессор
закачивает
воздух в цилиндр (2), пока давление не достигнет
максимального значения.
Если автоматическое реле давления (9) не
срабатывает, чрезмерное давление сбрасывается
через предохранительный клапан (11). Для
проведения ремонта обратитесь в официальный
сервисный центр IVT.
Тепловая защита (если имеется)
В компрессоре предусмотрена тепловая защита,
отключающая электродвигатель в случае перегрузки
(например, при засорении воздушного фильтра
(17)) или перегрева. Данная функция защищает
двигатель от перегрузки.
При срабатывании тепловой защиты необходимо
выключить компрессор и устранить причину.
Подождите, пока компрессор остынет, и продолжайте
работу.
Регулировка давления
Редуктор давления (21)
Редуктор давления (21) позволяет регулировать
давление воздуха на выходе из соединительного
штуцера (3) трубопровода с регулируемым
давлением в зависимости от степени потребления.
Установите необходимое давление; значение
давления показано на манометре (5):
∙
чтобы снизить давление: поверните рукоятку
редуктора давления (4) против часовой стрелки.
∙
чтобы повысить давление: поверните рукоятку
Содержание AC-100L2C
