5HP 80 gallon 1 Stage Single Phase 3 Cylinder Air Compressor –HP05V080Y1
7/18/2011
2
Introduction
Breathable Air Warning
This compressor/pump is NOT equipped and should NOT be used “as is” to supply breathing quality air.
For any application of air for human consumption, you must fit the air compressor/pump with suitable
in-line safety and alarm equipment. This additional equipment is necessary to properly filter and purify
the air to meet minimal specifications for Grade D breathing as described in Compressed Gas Association
Commodity Specification G 7.1 – 1966, OSHA 29 CFR 1910. 134, and/or Canadian Standards Associations
(CSA)
DISCLAIMER OF WARRANTIES
In the event the compressor is used for the purpose of breathing air application and proper in-line safety
and alarm equipment is not simultaneously used, existing warranties are void, and EMAX Air Force
Technology disclaims any liability whatsoever for any loss, personal injury or damage.
DANGER
!
CALIFORNIA PROPOSITION 65
This product or its power cord may contain chemicals known to the state of
California to cause cancer and birth defects or other reproductive harm.
Wash hands after handling.
WARNING!
READ INSTRUCTION MANUAL BEFORE OPERATING
RISK OF FIRE OR EXPLOSION
– DO NOT SPRAY
COMBUSTIBLE/FLAMMABLE LIQUID IN A CONFINED
AREA. SPRAY AREA MUST BE WELL VENTILATED. DO
NOT SMOKE WHILE SPRAYING OR SPRAY WHERE
SPARK OR FLAME IS PRESENT. ARCING PARTS – KEEP
COMPRESSOR AT LEAST 20 FEET AWAY FROM
SPRAYING AREA AND ALL EXPLOSIVE VAPORS.
RISK OF INJURY
– DO NOT DIRECT AIR STREAM AT
BODY. USE EYE PROTECTION. COMPRESSOR STARTS
AUTOMATICALLY. MOVING PARTS. DO NOT TOUCH.
KEEP GUARDS IN PLACE. COMPRESSOR DOES NOT
SUPPLY BREATHABLE AIR.
RISK OF BURSTING
– DO NOT ADJUST REGULATOR
TO RESULT IN OUTPUT PRESSURE GREATER THAN
MARKED MAXIMUM PRESSURE OF ATTACHMENT. IF
A REGULATOR HAS NOT BEEN INSTALLED -
USE ONLY ATTACHMENT RATED AT 200 PSI OR
HIGHER. DO NOT WELD ON OR REPAIR TANK –
REPLACE. DO NOT OPERATE WITHOUT PROPER ASME
SAFETY VALVE IN PLACE.
RISK OF ELECTRICAL SHOCK
– HAZARDOUS VOLTAGE:
DISCONNECT FROM POWER SOURCE BEFORE
SERVICING. COMPRESSOR MUST BE GROUNDED. DO
NOT USE GROUNDING ADAPTORS. DO NOT EXPOSE
TO RAIN. STORE INDOORS.
IF CONNECTED TO A CIRCUIT PROTECTED BY FUSES, USE
TIME-DELAY FUSE MARKED “D”
COMPLIES WITH CCR462 (L)(2).
DO NOT USE BELOW GARAGE FLOOR OR GRADE
LEVEL
DRAIN TANK EVERYDAY TO PREVENT CORROSION AND
POSSIBLE INJURY DUE TO TANK DAMAGE
