Hitachi DSP-110A6N, Инструкция по эксплуатации

Страница: 78 / 126

9. MAINTENANCE [Standard Maintenance Schedule]
76
3
Annual and 3-year Schedule
(for 8,000 hours/year or less operation)
4
2-year and 4-year Schedule
(for 8,000 hours/year or less operation)
5
6-year (Overhaul)
(for 8,000 hours/year or less operation)
Part or Item Action
Category Type
Remarks
Every year Every 3-year Fixed/V A/W
Lubricating oil Replace ○ Fixed/V A/W
Joints, Bolts, Nuts Tighten/Check △ Fixed/V A/W
Gasket - Inter/Aftercooler condensate strainer Replace
○
Fixed/V A/W
O-ring - Inter/Aftercooler condensate strainer Replace ○ Fixed/V A/W
Oil filter (secondary) Replace ● Fixed/V A/W
Consumable parts - Suction throttle valve Replace
●
Fixed A/W
Seal washer - Suction throttle valve Replace ● Fixed A/W
Seal gasket - Suction throttle valve Replace ● Fixed A/W
Thermistor, Pressure sensor, PCB other Electric parts Check ▲ Fixed/V A/W Change any operating parts in need of replacement.
Cooling fan Check for crack/Clean ▲ Fixed/V A/W
Orifice - Aftercooler condensate Check/Clean
▲
Fixed/V A/W Clean as required.
Orifice and Check valve - Intercooler condensate Check/Clean ▲ Fixed/V A/W Clean as required.
Aftercooler/Intercooler/Oil cooler Check/Clean ▲ Fixed/V A/W
Hi-Precooler Check/Clean
▲
Fixed/V A only
Demister - Drain separator Check/Clean ▲ Fixed/V A/W
3-Way solenoid valve & Capacity control system Check ▲ Fixed A/W Replace as required.
Blowoff solenoid valve Check ▲ V A/W
Air relief valve Check/Clean ▲ Fixed/V A/W
Protection, Safety device Check ▲ Fixed/V A/W Change any operating parts in need of replacement.
Motors Check/Clean ▲ Fixed/V A/W Measure insulation resistance and clean.
Relay (Drain solenoid valve) Replace ● Fixed/V A/W
Part or Item Action
Category Type Remarks
2-year 4-year Fixed/V A/W
Control line filter element Replace
○
Fixed A/W
Blowoff solenoid valve (1) (2) Replace ● V A/W
Consumable parts - Oil pump Replace ● Fixed/V A/W
Check valve Replace
●
Fixed/V A/W
Solenoid valve - Intercooler/Aftercooler condensate Replace ● Fixed/V A/W Replace the strainer together.
Check valve and Strainer - Intercooler condensate Replace ● Fixed/V A/W
Check valve - Control line Replace ● Fixed A/W
VFD (Variable Frequency Drive) Check ▲ V A/W Clean the heat sink fin
Cooling capacity for VFD Replace ● V A/W
Cooling fan for control panel Replace ● Fixed/V A/W
PC Board - Inverter, Module, FFC (Flat cable)
Check/Clean/
Replace
● V A/W
Check for contamination and discoloration. Replace if
faulty. May be used further if appropriate. (Except FFC)
Part or Item Action Category
Type
Remarks
Fixed/V A/W
Airend (1st-stage, 2nd-stage) Replace ● Fixed/V A/W A whole airend is replaced with a new
Main motor bearing Replace ● Fixed/V A/W
Fan motor bearing Replace ● Fixed/V A/W
Demister - Drain separator Replace ● Fixed/V A/W
3-Way solenoid valve Replace ● Fixed A/W
Oil strainer (primary) Replace ● Fixed/V A/W
Control line filter - Condensate Replace
●
Fixed A/W
Oil level gauge Replace ● Fixed/V A/W
Shaft seal - Main motor Check/Clean ▲ Fixed/V A/W
Temperature control valve Replace ● Fixed/V A/W
Smoothing condenser - Controller Replace ● V A/W
PC board assembly
Check/Clean/
Replace
●
Fixed/V A/W
Check for contamination and discoloration.
Replace if faulty. May be used further if appropriate.
PC board - Inverter
Check/Clean/
Replace
● V A/W
Check for contamination and discoloration.
Replace if faulty. May be used further if appropriate.
Electromagnetic contactor Check ▲ Fixed/V A/W Replace as required.
Lithium battery Replace ● Fixed/V A/W
※
For the 3rd overhaul, the air ends shall be replaced with new ones.