28
7034-276E
October 13, 2015
MT. VERNON AE
A. Glass Replacement - Door Assembly
(Replace with 5mm ceramic glass only)
a. Swing open the face and remove the door from the
appliance by lifting the door off of the hinge pins and lay
on a fl at surface face down.
b. Using a Phillips head screw driver, remove 4 screws, 2
on the top and 2 on the bottom. Remove metal bracket
and then remove the glass.
Figure 28.1.
c. Replace with new glass with gasket.
d. Re-attach metal bracket with 4 screws.
e. Re-install door over hinge pins and close face.
6
Service Parts Replacement
• Glass is 5mm thick high temperature heat-re-
sistant ceramic glass.
• DO NOT REPLACE with any other material.
• Alternate material may shatter and cause
injury.
WARNING
Remove 4 screws
Glass with Gasket
Metal Bracket
Figure 28.1
B. Baffl e Removal
a.
The appliance must be in complete shutdown, completely
cool and the exhaust blower off
.
b. Open door.
c. The baffl e is located at the top inside of fi rebox.
d. Remove baffl e by placing a fl at head screw driver into the
slot of the latches located in the upper corners and push
down. The bottom of the latch will fall forward off of the
post. Lift the baffl e up and then out toward you.
Figure
28.2.
e. To replace the baffl e, place the 2 locating ears behind the
bottom edge and tilt the baffl e up and into place.
f. The baffl e must be centered in the fi rebox before latching
it in place. If it is not centered the latch is trapped between
the baffl e and side of the fi rebox instead of latching prop-
erly.
g. The bottom of the latches will fi t over the posts. Push the
top of the latch forward to lock latch into place.
WARNING
Cast iron is a very heavy material.
The baffl e is
made of cast iron and therefore is heavy and awkward
at times to maneuver. Clear and prepare your work
area before you begin.
Baffle
Latches
Insert flat head screw driver into “V”
section and push down and the bottom
of the latch will fall forward off of post
Locating ears - 1 on
each side. Fit behind
bottom edge.
Figure 28.2
Handle glass doors with care.
• Inspect the gasket to ensure it is undamaged.
• Do NOT strike, slam or scratch glass.
• Do NOT operate appliance with glass door
removed, cracked, broken or scratched.
WARNING
