Gulfstream GS A-Class 12/OV, Инструкции по проектированию, установке и обслуживанию

Страница: 2 / 44

Supplied By www.heating spares.co Tel. 0161 620 6677
Page 2
1. Handling and Storing the Appliance
This appliance should be handled carefully to avoid damage and the recommended
method is shown opposite. A team lift - When lifting the unit:-
• Work with someone of similar build and height if possible.
• Choose one person to call the signal
• Lift from the hips at the same time, and then raise the unit to the desired level.
• Move smoothly in unison.
The appliance is supplied shrink wrapped on a timber installation base. Carrying
handles are provided towards the top of the left hand side of the casing and at the
bottom of the opposite side.
If the unit needs to be stored prior to installation it should be stored upright in a dry
environment and on a level base/floor.
Note: Although the above guidance is provided any manual handling/lifting
operations will need to comply with the requirements of the Manual Handling
Operations Regulations issued by the H.S.E.
The appliance can be moved using a sack truck on the left hand face although care
should be taken and the route should be even. In apartment buildings containing a
number of storeys we would recommend that the appliances are moved vertically
in a mechanical lift. If it is proposed to use a crane expert advice should be obtained
regarding the need for slings, lifting beams etc.
TM
benchmark
The code of practice for the installation,
commissioning & servicing of central heating systems
2. System Installation
Any installation must be in accordance with the relevant requirements of the current
issue of Gas Safety (Installation and Use) Regulations, Local Building Regulations, Local
Water Company Bylaws and Health & Safety Document No. 635 – The Electricity at
Work Regulations 1989. The detailed recommendations are contained in the current
issue of the following British Standards and Codes of Practices: -
BS 5440 Pts. 1 & 2; BS 5449; BS 5546; BS 7074 Part 1; BS 6700; BS 6798; BS 6891, BS
7593, IGE/UP/7/1998
3. Gas Consumer Council
The Gas Consumer Council (GCC) is an independent organisation which protects
the interest of all gas users. If you need advice, you will find the telephone number
in your local telephone directory under Gas.
4. Equipment selection
This information is provided to assist generally in the selection of equipment.
Responsibility for selection and specification of our equipment must, however,
remain that of our customers and any expert or consultants concerned with the
installation(s). Therefore please note that: -
a) We do not therefore accept any responsibility for matters of design selection or
specification for the effectiveness of an installation containing one of our products.
b) All goods are sold subject to our Conditions of Sale which are set out in the
Appendix to this document.
4. Warnings
a) The GulfStream
A-Class
is for use on Natural Gas only and must not be used on any
other gas.
b) This appliance must be serviced and installed by a competent person e.g. CORGI
Registered installer. All CORGI registered installers carry a CORGI ID Card and have a
registration number. You can call CORGI direct on 01256 372300.
c) As part of the industry wide ‘Benchmark’ initiative all GulfStream
A-CLASS
appliances
now include a Benchmark Installation, Commissioning and Service Record Logbook.
Please read this carefully and complete all sections relevant to this appliance. Failure
to do so may affect warranty.
d) If sealed components in the appliance are replaced and/or re-commissioned
in the field then these must be done strictly in accordance with manufacturer’s
instructions and these components must be re-sealed.
IMPORTANT NOTICES
5. Continuous Improvements
In the interest of continuously improving the
GulfStream
A-CLASS
range, Gledhill Water Storage
Ltd reserves the right to modify the product
without notice and in these circumstances this
booklet which is accurate at the time of printing
should be disregarded.
Issue 1: 03-05