GREAT PLAINS NTA3007HD, Руководство оператора

Страница: 70 / 178

Great Plains | 166-207M | 02/26/2019 Table of Contents Index 64
NTA907HD and NTA3007HD Table of Contents Index Operating Instructions
Unloading Materials
Unloading Safety Information
Unloading materials has the same risks as loading
material. Review the advisories on page 53.
Unloading Without Auger
1. Raise, fold, tilt and hook drill (page 34).
2. Position drill on smooth paved surface, or large tarp.
Put tractor in Park and shut off tractor. Engage
optional parking brakes on drill.
3. If unloading front hopper, drape a tarp over the
openers, to ease clean up.
4. Lower ladder (page 44), and open lid (page 45) on
any hopper to be emptied. Unless both hoppers
contain the same material, empty only one at a time.
5. If unloading fertilizer or treated seed, take same
materials safety protection measures as for loading.
Refer to Figure 70
6. Open Calibration door first. A small amount of
material may fall onto the collection area.
7. Open Clean-Out door second. Expect material to
flow in significant volume until the hopper is empty.
8. Install the calibration crank (page 56). Rotate it until
no material flows from the calibration door.
9. If the drill will not be used again for an extended
period, complete the steps at “
Material Clean-Outs ”
on page 107.
10. If unloading front hopper, and openers were not
covered with a tarp, brush excess materials from
openers.
11. Move drill from collection area and recover materials.
12. Wipe down doors and bottom of meter.
13. Close doors. For temporary parking or transport, fully
close doors. For storage, close doors only until
elastomer seals begin to touch meter housing, so
that condensation can drain. Do not leave doors
open wide enough for pest entry.
Auger Unloading: Rear Hopper
1. Position drill well clear of overhead electrical lines.
2. Raise openers (page 33) and fold wings (page 35).
3. Lower openers (page 32) to provide maximum
clearance at center section.
4. Shut down hydraulics or set Fan/Auger circuit to
Float or Neutral.
5. Open lid slightly on rear hopper.
Entrapment and Rapid Suffocation Hazard:
Never enter a hopper for loading or unloading.
Possible Chemical Hazard:
Agricultural chemicals can be dangerous, including
treatments on seeds and components of fertilizers. Improper
use can seriously injure persons, animals, plants, soil and
+
1
2
Figure 70
Meter Doors Open
26341
2
1
Unload Prep.: Hydraulic Circuit Operation
Lift
Fan,
Auger
Fold, Tilt,
Marker
Transport
Hooks
Neutral
Float or
Neutral
Neutral Neutral