10
ECONCEPT 100
Safety
elements
GAS
DELIVERY
RETURN
Generators connected in this way can be considered a single “equivalent” heat generator with a total power
of N x 90.4 kW. All the requirements of current standards and regulations applicable to this “equivalent”
generator with total heating power of N x 90.4 kW must be met. In particular, the place of installation,
safety devices and fume extraction system must be adequate for the total heating power N x 90.4 of the
bank of Econcept 100 units.
It is pointed out that each Econcept 100 module is in fact a complete independent heat generator, equipped
with its own safety devices. In particular, each Econcept 100 module is equipped with a water pressure switch,
safety thermostat and electronic limiting device. In case of overtemperature, no water or no circulation in
the unit, the protection devices cause the unit to switch off or shut down, preventing its operation.
The installation instructions given in the following paragraphs concern both single modules and cascade
connections.
Fig. 4
2. INSTALLATION
2.1 General Instructions
This appliance must only be used for its intended purpose. This unit is designed to heat water to a tempera-
ture below boiling point at atmospheric pressure and must be connected to a heating system compatible
with its performance, characteristics and heating capacity. Any other use is considered improper.
THE GENERATOR MUST ONLY BE INSTALLED BY QUALIFIED PERSONNEL, IN ACCORDANCE
WITH ALL THE INSTRUCTIONS GIVEN IN THIS TECHNICAL MANUAL, THE PROVISIONS OF CUR-
RENT LAWS, THE PRESCRIPTIONS OF NATIONAL AND LOCAL STANDARDS, AND THE RULES
OF PROPER WORKMANSHIP.
Incorrect installation can cause damage or injury, for which the manufacturer declines any liability.
2.2 Connection in cascade
Econcept 100 is a heat generator designed to operate separately or in cascade. If the heating power re-
quired by the system exceeds 90.4 kW, two or more Econcept 100 generators can be connected in cascade
(max. 5 heat generators), as shown by way of example in the figure.
