PAGE 19
PROBLEM
POOR DUST CONTROL
POOR SWEEPING QUALITY
MAIN BROOM NOISY
REAR TIRES NOISY
POOR TRACTION
SHORT RUN TIME
CAUSE
FILTER CLOGGED
HOPPER NOT CLOSED TIGHTLY
HOPPER GASKET FAULTY
HOPPER FULL
FAULTY VACCUM FAN
BATTERY CHARGE IS LOW
WET SEEP BY-PASS DOOR IS OPEN
MAIN BROOM WORN OUT
DEBRIS STUCK TO MAIN BROOM
BROKEN MAIN BROOM BELT
BROKEN MOTOR TO JACKSHAFT BELT
MAIN BROOM BELT FELL OFF
MOTOR TO JACK SHAFT BELT FELL OFF
BATTERY CHARGE IS LOW
BROOM HAS FLAT SPOT AND HAS
"BROOM BOUNCE"
DEBRIS STUCK IN MAIN BROOM
MAIN BROOM OUT OF ROUND
DEBRI STUCK IN MAIN BROOM BELT
BEARINGS DRY
FAULTY HUBS
EXCESSIVE MAIN BROOM PRESSURE
WORN DRIVE TIRES
BATTERIES RUN DOWN
BATTERIES STILL DOWN
BATTERIES LOW ON WATER
BATTERIES OVER CYCLED
SOLUTION
TURN ON FILTER BEATER
ADJUST SCREW ON HOPPER CLAMP
TO TIGHTEN SEAL
CONTACT LOCAL SERVICING DEALER
REMOVE DEBRIS
CONTACT LOCAL SERVICING DEALER
CHARGE BATTERIES OVER NIGHT
CLOSE BY-PASS DOOR.
REPLACE MAIN BROOM
REMOVE DEBRIS
REPLACE BELT
REPLACE BELT
PUT BELT BACK ON
PUT BELT BACK ON
CHARGE BATTERIES OVER NIGHT
REPLACE BROOM.
REMOVE DEBRIS
REPLACE MAIN BROOM
REMOVE DEBRIS
GREASE BEARINGS
CONTACT LOCAL SERVICING DEALER
REDUCE PRESSURE WITH SWITCH
CONTACT LOCAL SERVICING DEALER
CHARGE BATTERIES TWICE
CONTACT LOCAL SERVICING DEALER
FILL WITH DISTILLED WATER TO 3/4"
ABOVE THE LEAD PLATES
CONTACT LOCAL SERVICING DEALER
TROUBLE SHOOTING
