ENERGY KING 35EKB, Инструкция по установке, эксплуатации и обслуживанию

Страница: 29 / 76

Rev 07/13/09 ENERGY KING™ Wood/Coal Boiler Owner’s Manual
Š
U. S. 23
Operation
First Fire
Before lighting your first fire, inspect your
ENERGY KING Wood/Coal Boiler to ensure
that it has been properly installed and that all
safety requirements have been met. During
your inspection, pay particular attention to the
clearances to combustibles, venting, and
thermostat installation instructions.
Verify the Pressure Relief Valve’s proper
functioning by manually opening the valve and
releasing water into the floor drain. If no water
flows, do not operate the Boiler until a new
Pressure Relief Valve is installed.
Check to make sure that your combustion
blower is in proper working order. You can
check the forced draft blower by turning the wall
thermostat supplied with your ENERGY KING
heating appliance to a high temperature. If your
forced draft blower turns on, you may set the
wall thermostat to the desired setting.
Next, make sure that the burn chamber is clear
of all objects.
Do not fully load your ENERGY KING
Wood/Coal Boiler until you become familiar with
the operation of your ENERGY KING
Wood/Coal Boiler.
Some odors may be given off a new ENERGY
KING Wood/Coal Boiler during the initial few
hours of burning while the steel and the paint
are being cured. Ventilating the room until the
odors disappear is recommended.
Typical Operation Cycle
After a fire has been established and the operating temperature has been reached, only the wall
thermostat needs to be set to maintain the desired temperature. Your draft system is controlled
primarily by the wall thermostat; therefore it is crucial to ensure proper placement and installation of
the wall thermostat.
•
When your home cools, the wall thermostat
located in the living area of the home
activates the combustion blower, forcing
combustion air into your burn chamber.
•
As the fire burns hotter, the temperature of
your heating water increases and activates
your circulation system to deliver heat to your
home.
•
When the thermostat is satisfied, it will
deactivate your forced draft control system,
allowing the fire to cool until the next time
your thermostat calls for heat.
Your ENERGY KING Wood/Coal Boiler can run efficiently over extended periods of time and at
different heat output levels as long as the fuel supply is uninterrupted and cleaning and
maintenance are performed routinely.