E-Z-GO 625619 2012, Руководство по ремонту и обслуживанию техника, Страница: 150 / 182

Page N-2
Repair and Service Manual
B
TROUBLESHOOTING
Read all of Section B and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
STARTER ROTATES BUT VEHICLE
WILL NOT START OR HARD TO
START Weak Battery Recharge or replace as necessary
Corroded or loose battery connections Clean and tighten battery connections.
Apply a coat of battery protectant to
terminals
Check for adequate fuel level Fill with correct grade gasoline to 1"
(2.5 cm) below bottom of filler neck
No spark at spark plug. Broken or
disconnected spark plug wire Check and replace if required
Spark plug fouled Clean or replace
Broken or disconnected coil wires Check or replace
Faulty magneto Check or replace
Incorrect spark plug gap/type Set gap correctly
Fuel pump faulty Repair or replace
Fuel line clogged or clamp loose Clean or replace if required
Cracked or broken fuel line Replace with new hose
Main jet blocked Clean jet
Throttle lever motion restricted Check all linkages
Dirt or water in fuel line or carburetor Clean lines and carburetor. Replace filter
Clogged fuel filter Check and replace if required
Incorrect carburetor float setting Check/Replace float
Engine flooded Push choke in. Clean/or replace spark
plugs
Engine fuel starved Use choke and push in as soon as engine
runs smoothly
Air intake tube is blocked Repair or clean
Clogged air filter Wash or replace as required
Plugged muffler or pipe Repair or replace
Low compression in engine Check and repair
Condition Possible Cause Correction