l
Section 5: Troubleshooting
– this section describes troubleshooting using signals from the
compressor to determine the specific source of faults at the system and compressor level
l
Section 6: Maintenance
– this section contains a table containing a list of tasks that should be
performed on a regular basis to maintain optimal performance of the system
l
Appendix A: Acronyms/Terms
– this section provides definitions of terms and acronyms used in
this manual
l
Appendix B:
Compressor Troubleshooting Flowcharts
– this section contains flowcharts to assist
you with compressor troubleshooting
l
Appendix C: Compressor Test Sheet
– this section contains a sheet with test points, expected
values, and the section in the manual associated with a particular test
The following conventions are used in this manual:
l
Procedures – all user procedures are listed in numerical steps, unless it is a one-step procedure. A
one-step procedure is shown as a bullet.
l
User Action Required (software) – if a user is required to take action in a software procedure, the
action will be shown in bold. Example; When the Login window opens, type in
your name and
password
.
l
Monitoring Program Window Names – all window names will be in italic. Example
Compressor
Controller window
.
l
Internal References – references to sections within this manual are encapsulated in quotes.
Example, Isolate the compressor power as described in the “Electrical Isolation of the Compressor"
section of this manual.
l
External References – references to items not within this manual are underlined. Example; Refer to
the TTS/TGS/TTH/TGH Applications Manual for installation procedures.
1.4 Commitment to Quality and the Environment
Danfoss Turbocor Compressors (DTC) is dedicated to leading through innovation and to satisfying our customers
with the best quality, value, and on-time delivery of high-efficiency oil-free centrifugal compressors.
We are committed to controlling our impact on the environment demonstrated through setting goals focused on
continual improvement and complying with all relevant legislation, regulation, and other requirements to protect
the environment.
1.5 Safety Summary
Safety precautions must be observed during installation, start-up, and service of the compressor due to the
presence of pressure and voltage hazards. Only qualified and trained personnel should install, start up, and service
Danfoss Turbocor compressors. Safety information is located throughout the manual to alert service personnel of
potential hazards and is identified by the headings
DANGER
and
CAUTION
.
1.5.1 Danger Notification
A
DANGER
notification signifies an essential operation or maintenance procedure, practice, or condition which, if
not strictly observed, could result in injury to or death of personnel or long-term health hazards. A Danger
notification is displayed in the format shown in Figure 1-3 Danger Notification Example.
Figure 1-3 Danger Notification Example
• • • DANGER! • • •
Page 20 of 294 - M-SV-001-EN Rev. H 1/23/2023
Содержание Turbocor TT Series
