CPG CBL15, Инструкция по установке и эксплуатации, Страница: 8 / 16

8
DAILY CLEANING:
Remove the grease pan, empty and wash it.
Grate "burn o ff '. The grease buildup on the grates should be cleaned daily (more o ft en as needed).
A.
Cau ti on
: When handling grates or radiants, always use insulated gloves to prevent burns.
B.
Warning
: Do not cover the top of the grid grates during a burn o ff opera ti on. Restric ti ng the air fl ow by
covering the grid grates may cause them to warp. It will also cause damage to the valves, the knobs and the
front panel decal.
C. Place grates on broiler, with grid bars horizontal, facing down.
D. Turn the broiler on for approximately 45 minutes.
E. Turn o ff the broiler and allow it to cool for 20 minutes.
F. Clean top and bo tt om surfaces of grate with a wire brush to remove animal fats and carbonized grease.
G. Clean channels on grates with a scraper.
H. Remove grates from broiler. Clean top surface of radiants with wire brush. They may be cleaned in place.
NOTE : Parts protected by the manufacturer or his agent are not to be adjusted by the installer, unless the
installer is an authorized service agent.
TOUBLESHOOTING GUIDE
PROBLEM POSSIBLE CAUSE
Heat does not come
on when valve is on.
Pilot burner not lit.
Gas valve is bad.
Pilot burner will not light.
Obstructed pilot ori fi ce.
Pilot valve turned off.
Pilot burner will not stay lit.
Obstructed pilot ori fi ce.
Gas supply is not purged of air.
Air is blowing pilot light out.
Fat appears to smoke excessively.
Heat is set too high.
Moisture in the food may be turning into steam.
Food s ti cks to grates.
Heat is set too high.
Char Broiler surface needs cleaning and/or seasoning.
Surface under food may not have been covered with enough cooking oil.
Food is undercooked inside.
Heat is set too high or too low.
Food may not have been cooked for long enough
ti me.
Food tastes greasy or has
objec ti onable off- fl avor.
Food itself may have off fl avor.
Food may have been stored improperly before cooking.
Too much fat used.
Heat is set too low.
PLACE LAVA ROCK WITH AIR SPACES BETWEEN THE ROCKS. DO NOT OVERLOAD ROCK GRATES.
Please use the following amount of lava rock per model:
CBL15 : 30pcs
CBL24 : 60pcs
CBL36 : 90pcs
CBL48 : 120pcs