Club Car 2004 DS Gasoline, Руководство пользователя

Страница: 39 / 60

Battery Charger – Electric Vehicle
2004 DS Golf Car Owner’s Manual Page 37
BATTERY CHARGER – ELECTRIC VEHICLE
∆
DANGER
• The charging area must be ventilated. Hydrogen level in the air must never exceed 2%. The
total volume of air in the charging area must be changed five times per hour. Exhaust fans
should be located at the highest point of the roof. Contact a local HVAC engineer.
• Do not charge the vehicle batteries with the vehicle covered or enclosed. Any enclosure or
cover should be removed or unzipped and pulled back when batteries are being charged. An
accumulation of hydrogen gas could result in an explosion.
∆
WARNING
• Only trained technicians should repair or service the charger. Contact your nearest Club Car
distributor/dealer.
• Each charger should have its own dedicated 15 or 20 ampere separately protected (circuit
breaker or fuse) single phase branch circuit, in accordance with all applicable electrical codes
for the location.
• Connect the charger AC supply cord to a properly grounded, three-wire outlet of the proper
voltage and frequency as shown on the charger.
• Do not use an adapter to plug the charger with a three-prong plug into a two-prong outlet.
Improper connection of the equipment-grounding conductor can result in a fire or an
electrical shock.
• An extension cord or electrical outlet must accept a three-prong plug. Extension cord should
be a three-wire No. 12 AWG, and be as short as possible. The use of improper extension cord
could result in fire or an electrical shock.
• Do not operate the charger if it has received a sharp blow, was dropped, or otherwise
damaged in any way.
• Have worn, cut, or damaged power cords or wires replaced immediately.
• Do not use near fuels, grain dust, solvents, thinners, or other flammables. Chargers can ignite
flammable materials and vapors.
• Do not expose to rain or any liquid. Keep the charger dry.
• Never push objects of any kind into the charger through cabinet slots. They may touch
dangerous voltage points or cause an electrical short circuit that could result in fire or
electrical shock.
• Do not connect a stationary charger to the receptacle if the charger cord, plug, or the vehicle
receptacle is broken, damaged, or does not make a good electrical connection. Fire or
personal injury can result. Have a qualified technician replace the parts.
• 36-Volt Accu-Power Charger: Do not disconnect the DC output plug from the vehicle
receptacle when the charger is on. The resulting arcing and burning could damage the plug
and receptacle and could cause batteries to explode. If the charger must be stopped,
disconnect the AC supply plug from the wall outlet before disconnecting the charger DC cord
from the vehicle receptacle.
• 48-Volt PowerDrive Charger: When the charger is on, the charger DC cord may be
disconnected from the vehicle receptacle slowly. Jerking or pulling the DC cord out quickly
could cause arcing and burning that could damage the plug and receptacle and could cause
batteries to explode.
WARNING CONTINUED ON NEXT PAGE...