7
6.
It is important to deploy the plastic shield
enclosed in the unit. This plastic shield
prevents most of the foam or bubbles
from being sucked back inside the Super
Foam Dome
TM
fan intake. Slide the
shield half #1 onto the fan outlet, behind
the modulator (sock) and under the tip of
the molded handle located on the blower
and molded strip under machine. Slide
the shield half #2 onto the other side so
that they come together. A hole lines up
with hole from the other shield. Place the
small bolt through the hole to connect the
washer and nut. Tighten the nut securely,
locking the shield in place.
7.
Make sure unit is supported and secure before supplying power and fluid to unit. Shield
should be facing the floor with the modulator (sock) pointing straight down. Never point
modulator upward as this would cause electrical damage and ruin your unit.
5.4
Operating the machine
1.
Review electrical connections: The red power switch should be OFF. The GFI should be
plugged into a properly grounded outlet. Plug both the Super Foam Dome
TM
and the
pump from the barrel into the GFI. Both units need to always come on at the same time.
o
Never turn on the pump without the Super Foam Dome
TM
fan.
This will cause
fluid to pour from fan area to floor. Unplug the pump if you need to test only the fan.
When done, switch GFI off and plug the pump back in to GFI to operate the system.
Never operate without all lines and hoses attached.
2.
The Super Foam Dome
TM
and the pump will both turn on when you switch on the red
power switch on the GFI. The machine will slowly start spraying small amounts of fluid,
saturating the modulator with fluid. Once saturated, large volumes of foam will appear
and continue to increase in size all around the modulator.
3.
Do not run pump if fluid is unavailable. This may damage the pump.
4.
The pump uses 5 gallons in about 5 minutes. A 55-gallon drum of fluid will last about 55
minutes. The Super Foam Dome
TM
will produce 500 cubic feet (14m
3
) per minute of
foam, filling a 20’ x 20’ x 6’ volume in less than five minutes.
