11
SETUP
Hydrocollator® Heating Units
Remove all of the contents inside the Hydrocollator Heating Unit and then replace the wire
rack . Make certain the drain valve is closed before filling the tank with water . The tank should
be approximately 3/4 full with packs removed . The tank may be filled from any standard type
faucet .
Check the voltage rating on the serial decal plate which is located on the back of the unit . To
turn the unit on, simply plug the unit into a 120 Volt~, 60 Hz outlet as indicated on the decal
plate . To turn the unit off, simply unplug from outlet . Do not attempt to use direct current .
Follow the procedures indicated in the Precautionary Instructions . Do not attempt to use the
unit if it is not properly grounded .
OPERATION
The Hydrocollator Heating Unit is simple and easy to operate . The controls are located in the
rear, near the bottom of the unit . The thermostat controls the temperature of the water . It is
located near the bottom of the unit on the control panel . It has been tested and preset at the
factory to normal operating temperature . If further adjustment is necessary, it can be easily
accomplished by turning the adjusting screw located on the thermostat .
Turning the outer
screw counterclockwise lowers the temperature, while turning it clockwise raises it.
NOTE: Do not turn the inner stem under any circumstance! Stem is preset by the
manufacturer.
The Hydrocollator Heating Units operate through the use of a hydraulic capillary-type
thermostat and can be left plugged in and turned on to provide a ready supply of heated
HotPacs .
The HotPac rack accommodates different sizes and types of packs .
SS-2 Unit
– The SS-2 unit comes complete with eight standard HotPacs .
M-2 Units
- The M-2 unit comes complete with 12 standard HotPacs .
M-4 Units
- The M-4 unit comes complete with 24 standard HotPacs .
SS Unit
– The SS unit holds eight Standard Size packs . Special rack holds two Neck Contour
packs .
E-2 Unit
– The E-2 unit comes complete with two Oversize, three Standard Size packs and
one Neck Contour pack .
E-1 Unit
– With the insert in, the rack accommodates four Standard Size packs .
