6
•
If you notice grease or other hot material dripping from grill
onto valve, hose or regulator, turn off gas supply at once.
Determine the cause, correct it, then clean and inspect valve,
hose and regulator before continuing. Perform a leak test.
•
Keep ventilation openings in cylinder enclosure (grill cart) free
and clear of debris.
•
Do not store objects or materials inside the grill cart enclosure
that would block the flow of combustion air to the underside of
either the control panel or the firebox bowl.
•
The regulator may make a humming or whistling noise during
operation. This will not affect safety or use of grill.
•
If you have a grill problem see the
"Troubleshooting”
Section.
•
If the regulator frosts, turn off grill and LP cylinder valve
immediately. This indicates a problem with the cylinder and it
should not be used on any product. Return to supplier!
Leak Testing Valves, Hose and Regulator
1.Turn all grill control knobs to OFF.
2.
Be sure regulator is tightly connected to LP cylinder.
3.
Completely open LP cylinder valve by turning hand wheel
counterclockwise. If you hear a
rushing sound
, turn gas off
immediately. There is a major leak at the connection.
Correct
before proceeding
.
4.
Brush soapy solution onto areas circled below, or other similar
fittings on your grill.
5.If “growing”
bubbles appear, there is a leak. Close LP cylinder
valve immediately and retighten connections.
If leaks cannot be
stopped do not try to repair.
Call for replacement parts.
6.
Always close LP cylinder valve after performing leak test by
turning hand wheel clockwise.
NOTE: Sideburner shelf
fascia and other parts not
shown for clarity.
• Outdoor gas appliance is not intended to be installed in or
on a boat.
• Outdoor gas appliance is not intended to be installed in or on
an RV.
• Never attempt to attach this grill to the self-contained LP
gas system of a camper trailer or motor home.
NOTE: Your grill may NOT
be equipped with a
sideburner.
WARNING
Safety Tips
•
Before opening LP cylinder valve, check the coupling nut for
tightness.
•
When grill is not in use, turn off all control knobs and LP
cylinder valve.
•
Never move grill while in operation or still hot.
•
Some surfaces will be hot during use. Use long-handled
barbecue utensils and oven mitts to avoid burns and splatters.
•
Maximum load for sideburner and side shelf is 10 lbs.
•
The grease tray or cup
must
be installed during use and
emptied after each use. Do not remove grease tray or cup
until grill has completely cooled.
•
Clean grill often, preferably after each cookout. If a bristle
brush is used to clean any of the grill cooking surfaces, ensure
no loose bristles remain on cooking surfaces prior to grilling. It
is not recommended to clean cooking surfaces while grill is hot.
• Do not use grill until leak-tested.
• If a leak is detected at any time, STOP! Turn off
gas at source and correct leak.
• If you cannot stop a gas leak by closing the LP cylinder valve
leave area and call your fire department!
WARNING
