MI182 REV.8 Page 1 of 2
CCI Thermal Technologies Inc. 2721 Plymouth Drive, Oakville, ON L6H 5R5 Tel. (905) 829-4422 Fax (905) 829-4430
www.ccithermal.com
ISO 9001:2000
INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS FOR
SERIES OK3 – INFRARED RADIANT HEATERS
FIRE/EXPLOSION HAZARD WARNING - During operation, take precautions to ensure that
combustible materials are always kept at a safe distance from the radiant energy. This heater is
not intended for use in hazardous areas where flammable vapours, gases or liquids or other
combustibles are present. Remember that objects placed under an infrared heater can take a while
to reach stabilized temperatures. If you are unsure of the suitability of the heater for the intended
application, check with the factory for recommendations. Failure to comply can result in personal
injury and/or property damage.
DESCRIPTION
1.0
The OK3 radiant heaters are suitable for comfort heating
use in non-hazardous areas protected from rain, snow or splashing,
where heating element temperatures in excess of 750°C(1382°F)
will not present the risk of fire or explosion. The heater does not
present a safety hazard when it is installed, operated and maintained
in accordance with these instructions.
2.0
The OK3 heater has two U-shaped metal sheath heating
elements factory interconnected in series or parallel depending on
voltage. Never change heaters which have been factory series
connected to a parallel connection.
3.0
Minimum space clearances from combustibles, when
heaters are horizontally mounted and installed, as listed in Table 1
following.
Table 1
Min. Spacing
From nearest wall
600 mm (24”)
From the ceiling
300 mm (12”)
INSTALLATION
The system designer is responsible for
the safety of this equipment and
adequate back-up controls and safety
devices must be installed. Failure to
comply could result in personal injury
and/or property damage.
Heaters must be wired by qualified
personnel in compliance with local
codes.
5.0
Verify that the nameplate voltage and wattage are suitable
for use on the available electrical power supply. Do not connect
the heater to an electrical supply voltage other than shown on the
product label.
Insulation contamination or moisture
accumulation can cause fault to the
element sheath generating arcing and
releasing molten metal. Install proper
ground fault protection to prevent
personal injury and/or property
damage.
6.0
The connection box volume is 3100 cm³(190 in³).
7.0
Supply conductors to the heater must be suitable for
110°C(230°C). The ground wire from the supply shall be connected
to the grounding connection located in the connection box.
8.0
The connection box has eight dual knockouts, ½" or ¾"
and two dual knockouts ¾" or 1". The standard Type 1 enclosure
is suitable for dry, indoor locations only in non-corrosive
environments.
9.0
For short circuit protection, heaters must be installed with
proper fast acting fuses or breakers as close as possible to the
ratings indicated on the nameplates, in compliance with the local
electrical codes.
4.0
To facilitate mounting, the heater has four ¼"-20 mounting
holes located at each top corner of the housing. Either chain
mounting (use eye bolts) or bolting to a non-combustible sliding
support (slotted holes) is adequate provided that the spacing
instructions as given in 3.0 are followed. Chain mounting is preferred
since rigidly mounted heaters are susceptible to warping.
38 cm
[15”]
60 cm
[24”]
30
cm
[12”
]
FIG. 1 – MOUNTING CLEARANCES
MI102 REV.7 Page 4 of 6
CCI Thermal Technologies Inc. 2721 Plymouth Drive, Oakville, ON L6H 5R5 Tel. (905) 829-4422 Fax (905) 829-4430
www.ccithermal.com
TM
RENEWAL PARTS LIST / PIÈCES DE RECHANGE
Parts common to all GX heaters/ Piéce communes à tous les appareil GX
PART NO.
Q/HTR.
DESCRIPTION
DÉCRIPTION
NO. DE PIÈCE
QTÉ./APPAREIL
Fan Guard / Motor Mount
Protecteur Éventail / Montage sur le Moteur
C11080-01
1
Louvres
Volet Directionnel
B12352-02
7
Control Door
Porte de Cabinet de Contrôle
B11082-01
1
Thermostat
Thermostat
B11031-02
1
Fan Delay Relay
Relais / Délais D'Éventail
B11043-02
1
Hi-Limit
Haute-Limite
B11035-03
1
Knob
Bouton du Thermostat
B11037-01
1
Specific parts based on heater catalog number / Pièce communes à tous les appareil GX
50VA TRANSFORMER
CAT
VOLTS/
ELEMENT
MOTOR
(240V Secondary)
(C) CONTACTOR (240V Coil)
FANBLADE
NO.
PHASE
ÉLÉMENT
MOTEUR
TRANSFORMATEUR 50 VA
(C) CONTACTEUR (Bobine 240V)
ÉVENTAIL
(Secondaire 240V)
(3 Required/Requis)
(1 Required/Requis)
GX152
208/3
KXF10008-25
B11085-01
NONE/AUCUN
C11055-02
GX153
240/1
KXF10008-26
Check Factory/Vèrifiez auprès de l'usine
NONE/AUCUN
Check Factory/Vérifiez auprères de l'usine
C11028-09
GX157
480/3
KXF10008-27
B11085-03
B11033-04
C11055-01
GX158
600/3
KXF10008-28
B11085-04
B11033-05
C11055-01
(3 Required/Requis)
(1 Required/Requis)
GX202
208/3
KXF10008-29
B11085-01
NONE/AUCUN
C11055-03
GX203
240/1
KXF10008-30
Check Factory/Vérifiez auprès de l'usine
NONE/AUCUN
Check Factory/Vérifiez auprès de l'usine
C11028-09
GX207
480/3
KXF10008-31
B11085-03
B11033-04
C11055-01
GX208
600/3
KXF10008-32
B11085-04
B11033-05
C11055-01
(3 Required/Requis)
(1 Required/Requis)
GX252
208/3
KXF10008-33
B11085-01
NONE/AUCUN
C11055-03
GX253
240/1
KXF10008-34
Check Factory/Vérifiez auprès de l'usine
NONE/AUCUN
Check Factory/Vérifiez auprès de l'usine
C11028-09
GX257
480/3
KXF10008-35
B11085-03
B11033-04
C11055-01
GX258
600/3
KXF10008-36
B11085 -04
B11033-05
C11055-01
(3 Required/Requis)
(1 Required/Requis)
GX307
480/3
KXF10008-31
B11085-03
B11033-04
C11055-01
C11028-10
GX308
600/3
KXF1000-38
B11085-04
B11033-05
C11055-01
(6 Required/Requis)
(2 Required/Requis)
GX407
480/3
KXF10008-31
B11085-03
B11033-04
C11055-01
C11028-10
GX408
600/3
KXF10008-32
B11085-04
B11033-05
C11055-01
(6 Required/Requis)
(2 Required/Requis)
GX507
480/3
KXF10008-35
B11085-03
B11033-04
C11055-01
C11028-10
GX508
600/3
KXF10008-36
B11085-04
B11033-05
C11055-01
NOTE: Above catalogue numbers are for basic units without controls. Units with built-in contactors and/or thermostats use identitical
components.
NOTE: Les numéros de catalogue représentent les appareils sans contrôles. Pours les appareils comprenenant des contacteurs et/ou des
thermostats intégrés, utilisez les composants identiques.
MI102 REV.7.01 Page 4 of 8
RENEWAL PARTS LIST / PIÈCES DE RECHANGE
Parts common to all GX heaters/ Piéce communes à tous les appareil GX
DESCRIPTION
DÉCRIPTION
PART NO.
NO. DE PIÈCE
Q/HTR.
QTÉ./APPAREIL
Fan Guard / Motor Mount
rotecteur Éventail / Montage
sur le Moteur
C11080-01
1
Louvres
Volet Directionnel
B12352-02
7
Control Door
Porte de Cabinet de Contrôle
B11082-01
1
Thermostat
Thermostat
B11031-02
1
Fan Delay Relay
Relais / Délais D’Éventail
B11043-02
1
Hi-Limit
Haute-Limite
B11035-03
1
Knob
Bouton du Thermostat
B11037-01
1
Specific parts based on heater catalog number / Pièce communes à tous les appareil GX
NOTE: Above catalogue numbers are for basic units without controls. Units with built-in contactors and/or thermostats use identitical omponents.
NOTE: Les numéros de catalogue représentent les appareils sans contrôles. Pours les appareils comprenenant des contacteurs et/ou des thermostats intégrés, utilisez les
composants identiques.
CAT NO.
VOLTS/
PHASE
ELEMENT
ÉLÉMENT
MOTOR
MOTEUR
50VA TRANSFORMER (240V
SECONDARY)
TRANSFORMATEUR 50 VA
(SECONDAIRE 240V)
(C) CONTACTOR (240V
COIL)
(C) CONTACTEUR (BO-
BINE 240V)
FANBLADE
ÉVENTAIL
GX152
GX153
GX157
GX158
208/3
240/1
480/3
600/3
(3 Required/Requis)
KXF10008-25
KXF10008-26
KXF10009-27
KXF10008-28
B11085-01
Check Factory/Vèrifiez auprès de
l’usine
B11085-03
B11085-04
NONE/AUCUN
NONE/AUCUN
B11033-04
B11033-05
(1 Required/Requis)
C11055-02
Check Factory/Vérifiez auprès
de l’usine
C11055-01
C11055-01
C11028-09
GX202
GX203
GX207
GX208
208/3
240/1
480/3
600/3
(3 Required/Requis)
KXF10008-29
KXF10008-30
KXF10009-31
KXF10008-32
B11085-01
Check Factory/Vèrifiez auprès de
l’usine
B11085-03
B11085-04
NONE/AUCUN
NONE/AUCUN
B11033-04
B11033-05
(1 Required/Requis)
C11055-02
Check Factory/Vérifiez auprès
de l’usine
C11055-01
C11055-01
C11028-09
GX252
GX253
GX257
GX258
208/3
240/1
480/3
600/3
(3 Required/Requis)
KXF10008-29
KXF10008-30
KXF10009-31
KXF10008-32
B11085-01
Check Factory/Vèrifiez auprès de
l’usine
B11085-03
B11085-04
NONE/AUCUN
NONE/AUCUN
B11033-04
B11033-05
(1 Required/Requis)
C11055-02
Check Factory/Vérifiez auprès
de l’usine
C11055-01
C11055-01
C11028-09
GX307
GX308
480/3
600/3
(3 Required/Requis)
KXF10008-31
KXF1000-38
B11085-03
B11085-04
B11033-04
B11033-05
(1 Required/Requis)
C11055-01
C11055-01
C11028-10
GX407
GX408
480/3
600/3
(6 Required/Requis)
KXF10008-31
KXF1000-38
B11085-03
B11085-04
B11033-04
B11033-05
(2 Required/Requis)
C11055-01
C11055-01
C11028-10
GX507
GX508
480/3
600/3
(6 Required/Requis)
KXF10008-35
KXF1000-36
B11085-03
B11085-04
B11033-04
B11033-05
(2 Required/Requis)
C11055-01
C11055-01
C11028-10
