BC300E Broilchef LP Gas Grill
Owner’s Manual
3
For Your Safety
Dear Valued Customer,
Congratulations on your new barbecue grill purchase! You’ve made the right choice. In this manual, you will find assembly
instructions, suggestions for grilling and helpful hints, as well as guidelines for the safe operation, proper care and use of your
grill. Our expert staff strives to provide you with an easy-to-assemble product. Should you have any questions or problems with
this product, please call our customer service department at 1-855-630-5390, 07:00 am – 16:00 pm (EST), Monday through
Friday.
NOTE:
The use and installation of this product must conform to local codes. In the absence of local codes, use the National
Fuel Gas Code, ANSI Z223.1/ NFPA54. Reference to Natural Gas and Propane Installation code CSA B149.1 or Propane
Storage and Handling code B149.2
IMPORTANT NOTICE:
READ ALL INSTRUCTIONS PRIOR TO ASSEMBLY AND USE.
Safety First!
Read and understand all warnings and precautions prior to operating your grill.
WARNING:
1.
This grill is for outside use only. It should not be used in a building, garage or any other enclosed area.
2.
The use of alcohol, prescription or non-prescription drugs may impair an individual’s ability to properly assemble or safely
operate this appliance.
3.
Always open the grill lid carefully and slowly as heat and steam trapped within the grill could cause severe burns.
4.
Always place your grill on a hard and level surface far away from combustible materials and structures. An asphalt or
blacktop surface may not be acceptable for this purpose.
5.
Do not leave a lit grill unattended.
6.
Keep children and pets away from the grill at all times.
7.
This is not a tabletop grill. Do not place this grill on any type of tabletop surface.
8.
Do not use the grill in high winds.
9.
This grill must be used with propane gas only (propane gas cylinder not included).
10.
Do not attempt to attach this grill to the self-contained propane system of a camper, trailer, motor home or house.
11.
Do not use charcoal or lighter fluid.
12.
Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be constructed and marked in
accordance with the specifications for propane gas cylinders of the U.S. Department of Transportation (DOT) CFR 49.
13.
This outdoor gas appliance is not intended to be installed in or on recreation vehicles and/or boats.
14.
Do not attempt to move the grill while it is lit.
15.
Do not use the grill unless it is
COMPLETELY
assembled and all parts are securely fastened and tightened.
16.
Keep combustible items and surfaces at least
50 inches away from the grill at all times. DO NOT use this gas grill
or any gas product under any overhead enclosure or near any unprotected combustible constructions.
17.
Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other
flammable vapors and liquids.
18.
Do not attempt to use or assemble with missing or damaged parts. Contact customer service for replacement part.
CAUTION-Prevention of Burns
1.
To avoid burns, do not touch metal parts of the grill until they have completely cooled for at least 45 minutes or unless you
are wearing protective gear such as pot holders, protective gloves or mittens.
2.
Do not alter the grill in any manner.
3.
Clean and inspect the hose before each use. If there is evidence of abrasion, wear, cuts or leaks, the hose must be replaced
prior to operation. The replacement hose assembly should be in accordance with the manufacturer’s specifications.
4.
Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
5. Never
keep a filled gas container in a hot car or car trunk. Heat will cause the gas pressure to increase, which could open
the relief valve and allow gas to escape.
6. Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
Safe Locations For Use Of This Outdoor Grill
DANGER:
Never use this outdoor grill inside any building, garage, shed or breezeway, or inside any boat, trailer or recreational
vehicle to prevent a possible fire and to prevent the possibility of carbon monoxide poisoning or asphyxiation.
