Arctic Cat PANTERA 7000 2015, Руководство оператора

Страница: 37 / 64

33

NOTE: Take the snowmobile to an
authorized Arctic Cat Snowmobile
dealer for inspection and service.
This service is at the discretion and
expense of the snowmobile owner.
Battery (Pantera 7000)
These standard and sealed batteries after
being in service require regular cleaning
and recharging in order to deliver peak
performance and maximum service life.
The following procedures are recom-
mended for cleaning and maintaining
standard and sealed batteries. Always
read and follow instructions provided
with battery chargers and battery prod-
ucts.

NOTE: Battery maintenance may
be done by the snowmobile owner if
qualified to do so. If the owner does
not feel qualified, take the snowmo-
bile to an authorized Arctic Cat
Snowmobile dealer for this service.
This service is at the discretion and
expense of the snowmobile owner.
To remove and charge the battery, use the
following procedure:
1. Remove the rear and front seat.
2. Remove the negative battery cable
and ground wire; then remove the
positive cable.

NOTE: For installing purposes
prior to removing the battery, note
the routing and securing locations of
the cables and harness wires.
3. Remove the two lock nuts securing
the battery bracket/solenoid to the
seat-base; then move the bracket up
and out of the way and remove the
battery.
4. Thoroughly wash the battery with
soap and water; then using a wire
brush, clean the battery posts and
cable ends removing all corrosive
buildup. Replace damaged cables or
cable ends.

NOTE: If battery posts or cable
ends have a build-up of white/green
powder residue, apply water and
baking soda to neutralize acid; then
flush off with warm soapy water.
5. Using a multimeter, test battery voltage.
The meter must read no less than 12.5
DC Volts for a fully charged battery.
CAUTION
It is critical that the checking/adjust-
ing valve clearance be done at the
recommended intervals or severe
engine damage may occur.
! WARNING
Improper handling or connecting of a
battery may result in severe injury
including acid burns, electrical burns,
or blindness as a result of an explo-
sion. Always remove rings and
watches. Any time service is per-
formed on a battery, the following
must be observed: keep sparks, open
flame, cigarettes, or any other flame
away. Always wear safety glasses.
Protect skin and clothing when han-
dling a battery. When servicing a bat-
tery in an enclosed space, keep the
area well-ventilated.
! WARNING
Battery posts, terminals, and related
accessories contain lead and lead
compounds, chemicals known to the
state of California to cause cancer
and reproductive harm. Wash hands
after handling.
CAUTION
Make sure to disconnect the acces-
sory plug for the rear seat and the
front seat heater connector prior to
removing the seats.
! WARNING
Avoid spillage and contact with skin,
eyes, and clothing.
CAUTION
Do not charge the battery while it is in
the snowmobile with the battery ter-
minals connected.
CAUTION
Do not remove seal strip on a sealed
battery.
! WARNING
Battery acid is harmful if it contacts
eyes, skin, or clothing. Care must be
taken whenever handling a battery.