4-16
KC220
4. Mark the fuel pump and gas tank for proper orien-
tation during assembly; then disconnect the fuel
pump/fuel level sender connector.
KC423
5. Disconnect the gas line connector from the fuel
pump outlet.
6. Remove the screws securing the fuel pump to the
gas tank; then make a reference mark on the fuel
pump and tank.
7. Lift out the fuel pump assembly and carefully
guide the pump and float lever through the open-
ing in the gas tank.
8. Using duct tape or other suitable means, cover the
fuel pump opening.
INSPECTING
1. Inspect the fuel screen and blow clean with low
pressure compressed air.
2. Move the float lever and check for free movement.
The float assembly should return to the lower posi-
tion without force. If not, replace the fuel pump
assembly.
3. Test the fuel level sensor by connecting a multime-
ter (A) to the fuel level sensor leads (B); then
select OHMS. The multimeter should show 5
ohms at full fuel position (C) and 95 ohms at
empty fuel position (D).
ATV2116
NOTE: If readings are erratic, clean the resistor
wiper and resistor with clean alcohol and retest. If
still not correct, replace the fuel level sensor.
4. To replace the fuel level sensor, use the following
procedure.
A. Disconnect the two-wire connector (A); then
press the fuel level sensor toward the top of the
fuel pump to release it from the mounting slot
(B).
FI460A
B. Engage the tabs (C) of the fuel level sensor into
the mounting slot (B) and press toward the bot-
tom of the fuel pump to latch in place; then con-
nect the two-wire connector (A).
! WARNING
Gasoline may be under pressure. Place an absorbent
towel under the connector to absorb any gasoline
spray when disconnecting.
! WARNING
Do not turn the ignition switch to the ON position with
the hoses removed. Gasoline will be pumped by the
electric fuel pump causing a safety hazard.
CAUTION
Take care not to damage the float or float arm or
replacement of the entire assembly will be necessary.
AT THIS POINT
If the pump has failed earlier test and must be
replaced, proceed to INSTALLING.
Section
Table of Contents
Manual
Table of Contents
For Discount Arctic Cat Parts Call 606-678-9623 or 606-561-4983
www.mymowerparts.com