American Sportworks Utility Vehicl, Руководство оператора

Страница: 34 / 135

34
5. Replace filler cap/dipstick and tighten securely.
Engine Oil Change
Warms oil drains quickly and completely. Therefore,
drain used engine oil while engine is still warm as
follows:
1. Park vehicle on a level surface, set park brake,
turn off ignition switch, and remove switch key.
2. Place a suitable container below engine to catch
used oil. Remove filler cap/dipstick and drain
plug.
3. Allow used oil to drain completely and then
reinstall and tighten drain plug securely.
4. Dispose of used motor oil in a manner that is
compatible with the environment. Do not throw
used oil in the trash. Do not pour it on the
ground, or down a drain.
5. Fill oil to the outer edge of the oil fill hole with
recommended oil. Engine must be level when
filling.
6. Replace filler cap/dipstick and tighten securely.
SPECIAL NOTE: TO DRAIN ENGINE OIL
REMOVE REAR DRAIN PLUG ON ENGINE
Engine Oil Drain, Fill & Check Locations
Figure 5-4
Section 5 Maintenance
Transaxle Oil
A general description for transaxle oil maintenance,
recommendations, and capacities is provided below.
NOTE:
Running vehicle low on transaxle oil can
damage transaxle and void warranty.
Transaxle Oil Type, Fill, and Drain
Refer to Figure 5-5B
* Fill cap location: At rear left hand side (See arrow)
* Drain plug location: At bottom center of transaxle.
* Type of Lubrication: SAE 30W oil.
* Transaxle Lubrication Capacity: 20 oz.
Transaxle Oil Maintenance Schedule
* Check transaxle housing for damage and possible oil
leakage after each use.
* Check transaxle oil level every 6 months or every 200
hours (whichever comes first).
This can be accomplished by Parking vehicle on a level
surface, set park brake, turn off ignition switch, and
remove switch key, using a clean long bladed screw
driver (or similar object) insert into filler hole until it
touches the bottom of gear case. Remove the screw
driver. There should be approximately 2.1/4” to 2.1/2” of
oil visible on screw driver. Refer to Figure 5-5A
* Change transaxle oil once a year or every 600 hours
(whichever comes first).
Figure 5-5A