34
16599 rev. B pub. 11/07/2017
FUSES:
• In addition to the main fuse, there are three smaller fuses to
protect the 12 volt and 48 volt circuits . These fuses are shown
in figures 4 .25 & 4 .26 . Should these fuses blow and need
replacement, a replacement fuse of the same rating must be
used .
NOTE
ALL MODELS
CAUTION
CAUTION
ACCESSORY WIRING
Accessories must NOT be grounded to chassis . Damage to
converter will occur . Ground to distribution block ground
(neg) terminal only (see wiring diagram for proper distribution
block location)
Washing or operating the vehicle in freezing temperatures can
result in water freezing in the throttle cable conduit, the throttle,
and/or the engine’s throttle mechanism.
a . This may result in the throttle sticking which can cause the
engine to continue to run and result in loss of control .
BATTERY & ELECTRICAL CONT .
figure 4 .24 (battery charger)
figure 4 .25 (25 amp fuse)
figure 4 .26 (10 amp & 20 amp fuses)
figure 4 .27 (protecting the air intake)
48V MODELS
UNDER
AGE
16
E15
E85
section 4
maintenance
Washing your vehicle (ALL GAS MODELS)
It is acceptable to wash your utility vehicle, though a pressure washer should not
be used, and common sense should be exercised . The air intake system should be
protected during washing by placing a plastic bag or other protection over the top
of it and securing underneath prior to washing as shown figure 4 .27 . Avoid direct
water or spray contact with wiring harness, system components, or any electrical
component especially if the vehicle is equipped with EFI . Remember that the
electronics of a fuel injection system are sensitive to water and corrosion .