SAFETY DEVICE TESTING
6-5
10.The unit should shut down and again display
AIRFLOW FAULT DURING RUN
.
11.Return the Iris Air Damper to its previous
setting.
12.Press the
CLEAR
button. The unit should
restart.
6.9 SSOV PROOF OF CLOSURE SWITCH
The SSOV shown in Figure 6-1 contains a proof
of closure switch. The proof of closure switch
circuit is checked as follows:
1. Set the unit’s
ON/OFF
switch to the
OFF
position.
2. Place the unit in Manual Mode and set the
valve position between 25% and 30%
3. Refer to Figure 6-1 and locate the SSOV.
4. Remove the cover from the SSOV by
loosening the screw shown in Figure 6-4. Lift
off the cover to access the terminal wiring
connections.
5. Disconnect wire #148 from the SSOV to
“open” the proof of closure switch circuit.
6. The unit should fault and display
SSOV
SWITCH OPEN.
7. Replace wire #148 and press the
CLEAR
button.
8. Set the
ON/OFF
switch to
ON
to start the
unit.
9. Remove the wire again when the unit
reaches the purge cycle and
PURGING
is
displayed.
10.The unit should shut down and display
SSOV
FAULT DURING PURGE.
11.Replace the wire on the SSOV and press the
CLEAR
button. The unit should restart.
Figure 6-4
SSOV Actuator Cover Location
6.10 PURGE SWITCH OPEN DURING
PURGE
The Purge Switch (and Ignition Switch) is
located on the Air/Fuel Valve. To check the
switch, proceed as follows:
1. Set the unit’s ON/OFF switch to the
OFF
position. Place the unit in manual mode and
set the valve position between 25% and
30%.
2. Remove the Air/Fuel Valve cover by rotating
the cover counterclockwise to unlock it and
then lift up (see Figure 6-5).
3. Remove one of the two wires (#171 or #172)
from the Purge Switch (Figure 6-6).
4. Initiate a unit start sequence.
5. The unit should begin it’s start sequence,
then shut down and display
PRG SWITCH
OPEN DURING PURGE.
6. Replace the wire on the Purge Switch and
depress
the CLEAR
button. The unit should
restart.
Содержание Benchmark 3.0LN Series
