Access 7000, Руководство по установке

Страница: 7 / 143

SAFETY AND HEALTH
2 SAFETY AND HEALTH
2.1 SAFETY, GENERAL
Since this product may be installed in variety environments, only generic hazards are highlighted, sup-
plementary improvement measures determined by Risk assessment(s), (RA) will be required. Therefore,
before starting a new installation appraise the validity and completeness of the RA(s) provided. The line
manager must be consulted over any shortcomings and, if necessary, agreement reached over the need
for supplementary RA (s). National Statutory Regulations must be complied with and advisory codes ob-
served. This includes the provision of a method statement.
Generic Hazards associated with this type of task, the circumstances during which they are present and
improvement actions may be as follows:
2.1.1 HAZARDS
Falling from height: There is a risk of falling from the platform and unprotected upper door edges.
Risk reduction: Provide temporary barriers at entrances. Provide specific RA for use of the platform dur-
ing erection.
Trapping: During construction of the shaft, there is a risk of trapping between the platform and door
frame edges.
Risk reduction: Conduct supplementary RA.
Falling objects: It is possible that objects may fall from the platform and door openings.
Risk reduction: Provide kick boards at edges. Use appropriate PPE (Personal Protective Equipment).
High voltage: Electrocution.
Risk reduction: Turn off the mains isolator as detailed in these instructions when this hazard is present.
Manual handling: Trapping, crushes and strains. Cuts from sharp edges.
Risk reduction: Additional assistance and training. Use of handling aids - trolleys, chain block, PPE. Using
correct PPE
General hazard: During installation, there is a risk of that the lift may fall down which can cause severe
damage to the persons involved, the surroundings and the lift itself.
Risk reduction: During installation, do not load or stand on the platform before the lift is properly fixed
to the building according to chapter 4 REACTION FORCES .
2.2 WARNING TEXT
Warning text occurs where required and indicates that the text in question should be observed extra
carefully. The warning texts are marked as set out below:
DANGER
Indicates an immediate hazardous situation that, if not avoided, will result in death or
serious personal injury.
WARNING
Indicates an immediate hazardous situation that, if not avoided, can result in death or
serious personal injury .
7000 100 en-GB AD
3