3.) Clean strainer, bell trap and trapway with
mild soap and water.
** Important** Do not use heavy cleaners or
detergents.
Pour two to three gallons of warm water down
drain hole to flush urinal trapway and drain
line.
4.) Check o-ring on bell trap. Replace
if needed. Reinstall bell trap with o-ring.
Tighten snug with 3/8” rachet and exten-
sion turning clockwise. Be careful not to
overtighten.
Install strainer and refill trapway with
approximately 1 quart of water. Check
assembly for leaks. Add 4 ounces of Zurn
AquaGreen
TM
sealant to the trapway.
A
A
Cleaning (Continued)
Recommended Periodic Trap Cleaning (Every 9,000 Uses)
ZURN INDUSTRIES, INC.
♦
♦
♦
♦
♦
COMMERCIAL BRASS OPERATION
♦
♦
♦
♦
♦
5900 ELWIN BUCHANAN DRIVE
♦
♦
♦
♦
♦
SANFORD NC 27330
Phone: 1-800-997-3876
♦
♦
♦
♦
♦
Fax: 919-775-3541
♦
♦
♦
♦
♦
World Wide Web: www.zurn.com
In Canada: ZURN INDUSTRIES LIMITED
♦
♦
♦
♦
♦
3544 Nashua Drive
♦
♦
♦
♦
♦
Mississauga, Ontario L4V1L2
♦
♦
♦
♦
♦
Phone: 905-405-8272 Fax: 905-405-1292
FV379 7/06 REV B
Troubleshooting
PROBLEM
Strong odor is eminating
from urinal.
REMEDY
1.) Add 3-4 ounces of AquaGreen
TM
sealant
2.) Replace o-ring and/or screw bell
trap properly reassemble and refill
trapway with approximately 1 quart
of water and 4 oz. of sealant.
3.) Add 3 to 4 oz. of Zurn
AquaGreen
TM
sealant to trapway.
4.) Perform periodic trap cleaning
procedure. See trap cleaning on
page 5.
CAUSE
1.) AquaGreen
TM
sealant is depleted.
2.) O-ring seal is not adequate on bell
trap or bell trap is not screwed in
properly.
3.) AquaGreen
TM
sealant is depleted.
4.) Urine pathway is blocked with
sediment.
6