6F65G11
3-10
9
8
7
6
5
4
3
2
1
2.
Replace the anodes or trim tab if exces-
sively eroded.
Checking the battery
1.
Check the battery electrolyte level. If the
level is at or below the minimum level
mark
a
, add distilled water until the level
is between the maximum and minimum
level marks.
2.
Check the specific gravity of the elec-
trolyte. Fully charge the battery if below
specification.
w
Battery electrolyte is dangerous; it con-
tains sulfuric acid which is poisonous and
highly caustic.
9
Avoid bodily contact with electrolyte as
it can cause severe burns or permanent
eye injury.
9
Wear protective eye gear when handling
or working near batteries.
Antidote (EXTERNAL):
9
SKIN – Wash with water.
9
EYES – Flush with water for 15 minutes
and get immediate medical attention.
Antidote (INTERNAL):
9
Drink large quantities of water or milk
followed with milk of magnesia, beaten
egg, or vegetable oil. Get immediate
medical attention.
9
Charge batteries in a well-ventilated
area.
9
Keep batteries away from fire, sparks or
open flames (e.g., welding equipment,
lighted cigarettes).
9
DO NOT SMOKE when charging or han-
dling batteries.
KEEP BATTERIES AND ELECTROLYTE
OUT OF REACH OF CHILDREN.
6F630240
a
General
NOTE:
9
Batteries vary per manufacturer. The proce-
dures mentioned in this manual may not
always apply, therefore, consult the instruc-
tion manual of the battery.
9
Disconnect the negative battery lead first,
then the positive battery lead.
Lubricating the outboard motor
1.
Apply water resistant grease to the areas
shown.
NOTE:
Apply grease to the grease nipple until it
flows from the bushings
a
.
Electrolyte specific gravity:
1.280 at 20° C (68° F)
A
6F630250
A
6F630260
A
A
a
A
6F630270
Summary of Contents for E40G
