World Cat 2014 290DC, Owner'S Manual

Page: 39 / 98

2014 World Cat 290DC Owners Manual
World Cat uses vinyl, plexiglass, and polyethylene material (Starboard™) throughout the interior of our catamarans.
Use the following instructions to care for these items:
Use mild detergents to clean vinyl trim commonly used in cabins and helm. Routinely use a commercially available
surface protector to seal the vinyl.
Surface or glass cleaners can be used to clean plexiglass. It is commonly used for radio boxes and as a protective
material for instrument panels.
Starboard™ can be cleaned using surface cleaners such as 409™.
7.6 S
TAINLESS
/ A
LUMINUM
Stainless steel and aluminum are used throughout your vessel. World Cat uses only 316 marine grade stainless
hardware and anodized aluminum to provide you with years of service; however, these metals can deteriorate and fail
if improperly cared for. Upon returning, clean all hardware using a mild detergent and rinse thoroughly with fresh
water. Avoid using abrasive cleaners or chlorine based products, as they will remove the metal’s protective coating
and lead to pitting or rust. Throughout the year coat the metal using a non-abrasive metal protector to help displace
moisture, remove contaminates, and shield the metal. World Cat recommends high quality sealants such as Boeshield
T-9™ developed by Boeing™ Aviation. If you cannot find it locally call PMS Products Inc. at 800-962-1732.
7.7 B
ILGE
C
OMPARTMENTS
Routinely check the condition of the bilge compartments in your boat. This will help identify potential problems and
eliminate odors associated with stagnant water and the buildup of residue. Clean the compartments using a freshwater
rinse. This will also enable you to check the function of your drain system and the operation of the bilge pumps.
7.8 C
OCKPIT
D
RAINS
All World Cats have four drains located in the cockpit, two on both the starboard and port sides. These drains are
designed to quickly evacuate the cockpit should the boat become swamped. Flushing these drains routinely will
ensure the safety of your crew and vessel, as well as, eliminate the potential for odors associated with fish residue.
These drains are evacuated through the scuppers located on the hullside. Each scupper has a rubber flap to prevent
water from entering the boat. Check this material occasionally to keep them free of debris and in good working con-
dition.
7.9 W
INTERIZATION
Routine maintenance checks should be performed prior to each trip in accordance with Chapter 1, but a broader
analysis should be done before winterizing your catamaran and prior to the first trip of the season. If your local cli-
mate does not require winter storage, complete the following steps at least annually to ensure the safe operation of
your boat.
•
Do not leave loose items or personal affects onboard during storage. Remove all trash and debris prior to
cleaning the boat.
•
Before storage clean the boat thoroughly, including exterior surfaces, fishboxes, livewells, and thru hull
fittings. If possible leave lids open slightly to allow fresh air exchange. Remove the garboard drains and store
the boat with the bow up to allow drainage.
•
Inspect all electrical connections and the operation of pumps or other electrical devices. Perform repairs if
necessary. Coat electrical panels with an anti-corrosive spray, available from your dealer.
•
Inspect the batteries and charge fully to prevent damage during storage. Disconnect the cables and apply a
coat of grease to the terminals to prohibit corrosion.
Page 7-39