Worksman Trading Corp - 94-15 100
th
Street - Ozone Park, NY 11416 - (888) 3-WHEELER or 718 322 2000 – www.worksman.com
Parts list SBST-05
Drum Brake
: Your Worksman Tricycle is equipped with an automotive type front drum brake. This brake is ideal for slowing your
vehicle smoothly and reliably. It is engaged by squeezing the hand lever on the handlebar. To use “Park” feature, when cycle is
completely stopped, squeeze hand lever and push in parking plunger button on lever. To disengage, simply squeeze lever until
parking plunger button releases.
Drum Brakes are pre-adjusted at the factory. Readjust the cable tension as necessary using the adjusting barrel so that wheel
spins freely and stops when brake is applied. Always replace worn brake cables (F719-SBST) and damaged hand levers.
Internal parts are available for your Drum Brake (L725 parts kits and L709 axle set).
Coaster Brake:
Foot activated coaster brakes are easy to use and reliable. To activate this internal brake, reverse the pedaling
motion until the brake engages. To avoid skidding and maintain control, apply care when braking. This is especially true on wet
surfaces. Apply brakes gently, gradually increasing pedal back pressure. Replace coaster brakes when they become worn.
Check chain tension regularly. For models that are ordered with 3 Speed coaster brakes, the operation is the same. Simply select the gear you wish to
ride in. First gear is for easier starts and low speed riding. As you changed to gear 2 and 3 you will note that pedaling effort increases as does distance
traveled with each turn of the crank.
Tires:
Always check for worn or damaged tires. The Worksman Sup-r-tires are heavy duty. We recommend 40PSI as proper level of inflation.
Replace tires that are worn or cut immediately. Replace tubes that show leaks.
RULES FOR SAFE RIDING AND RESPONSIBLE OPERATION: Carefully read this manual before operating the cycle.
•
It is the responsibility of the assembler to properly install all parts included and to inspect the cycle prior to riding to insure proper operation.
•
Operator is responsible for required maintenance to keep the cycle in good operation condition
•
Observe all traffic regulations in the operating environment (stop signs, etc.) Ride in single file. Make certain route is wide enough for SBST.
•
Do not ride outdoors, at night. Have appropriate signaling device as needed. (We recommend the 3973 Mega Horn)
•
Give Pedestrians the Right of Way. Always look around you to understand the riding environment and hazards.
•
Do not carry passengers other than the two riders seated. Check brakes prior to riding. Both riders must understand vehicle’s operation.
•
Slow down when approaching turns or intersections. Tricycles are meant for slow pace rides, not for racing.
•
Use proper hand signals when turning or stopping. Recommended Safety Options: Approved helmet, audible warning device.
•
Never ride the cycle if there are known repairs required. Do not exceed the recommended weight capacity of the cycle (500 pounds)
•
Do not stack cargo too high in basket and always secure cargo with appropriate tie down straps.
•
Wipe surface of cycle clean and dry when exposed to corrosive substances or environment.
•
Operate Cycle at slow speeds; avoid areas with vehicular traffic.
•
Operators of cycles should be in good physical condition. Ride at your own risk.
•
Wear proper riding attire. Check shoelaces prior to riding so they do not become engaged in the chain and sprocket.
•
Ride only on smooth, paved surfaces. Do not use off road. Do not ride on steep grades…designed for relatively flat roads.
•
Do not operate a tricycle on steep grades. They are designed for relatively level, paved surfaces only.
•
Always replace worn parts with genuine Worksman Cycle Repair Parts. Keep a maintenance log for your records.
•
Designate a Captain. The Captain should keep both hands on the handlebars. SBST steers like a car…always turn slowly.
•
If motorized, buyer responsible for meeting local laws relating to motorized vehicles and viability of operation.
LIMITED WARRANTY:
THIS CYCLE IS WARRANTED AGAINST FAULTY PARTS UNER THE FOLLOWING CONDITIONS: THIS WARRANTY DOES NOT COVER ANY FAILURE DUE TO ACCIDENT, ABUSE, MISUSE,
NEGLECT OR AS THE RESULT OF NORMAL WEAR AND TEAR, OR IMPROPER ASSEMBLY. THE ENTIRE FRAME INCLUDING ALL WELDED JOINTS IS WARRANTED TO BE FREE FROM
DEFECTS AND MATERIAL FOR ONE YEAR WHILE IN POSSESSION OF THE ORIGINAL PURCHASER. ALL OTHER PARTS ON THIS CYCLE EXCEPT TIRES AND TUBES IS WARRANTED FOR
NINETY DAYS FROM THE DATE OF PURCHASE. REPAIR AND REPLACEMENT OF THESE PARTS IS TO BE ACCORDING THE WORKSMAN CYCLES PARTS AND SERVICE PROCEDURES
AND MUST BE HANDLED DIRECTLY THROUGH THE SOURCE WHERE THE CYCLE WAS PURCHASED. IF UPON EXAMINATION OF THE PARTS IN QUESTION, THE WORKSMAN CYCLE
DEALER DETERMINES THAT IT IS DEFECTIVE, EAITHER REPAIR OR REPLACEMENT WILL BE MADE AT NO COST EXCEPT THE COST OF TRANSPORTATION AND LABOR CHARGES (IF
ANY). UNAUTHORIZED REPAIRS OR REPLACEMENT AUTOMATICALLY VOIDS WARRANTY. PROPER MAINTENANCE IS REQUIRED FOR WARRANTY TO BE VALID. IN THE EVENT THAT IT
WAS DETERMINED THAT THE WARRANTY CLAIM IS THE RESULT OF MISUSE, ABUSE, IMPROPER MAINTENANCE OR SIMPLY NOT DEFECTIVE OR BEYOND THE WARRANTY PERIOD,
WORKSMAN CYCLES OR THE DEALER WILL ADVISE YOU AS TO THE COST OF REPAIR, REPLACEMENT OR LABOR PRIOR TO PERFORMING ANY WORK OR REPLACING ANY PARTS. IF
YOU CHOSE NOT TO HAVE THE DEALER OR WORKSMAN CYCLES PERFORM THE WORK, THE PARTS WILL BE RETURNED TO YOU AT YOUR EXPENSE OR DISCARDED IF NO REPLY IS
RECEIVED WITHIN 2 WEEKS OF NOTICIATION. THE SOLE RESPONSBILITY OF THE MANUFACTURER TO THE TERMS OF THIS WEARRANTY, IF ANY, SHALL BE THE REPAIR AND OR
REPLACEMENT OF THE PARTS AS INDICATED ABOVE. THE LIABILITY OF THE MANUFACTURER SHALL IN NO EVENT EXCEED THE ORIGINAL PURCHASE PRICE OF THE PRODUCT AND
THE MANUFACTURER SHALL NOT BE RESPONSIBLE FOR ANY CONSEQUENTIAL DAMAGES OF ANY NATURE, INCLUDING, BUT NOT BY WAY OF LIMITATION, DAMAGES FOR
PERSONAL INJURY OR PROPERTY.THIS STATEMENT CONSTITUTES THE EXCLUSIVE EXPRESSION OF WARRANTIES BY THE MANUFACTURER AND IS IN LIEU OF ANY OR ALL OTHER
WARRANTIES SUCH AS EXPRESSED WARRANTIES, IMPLIED WARRANTIES, INCLUDING BUT NOT LIMITED TO WARRANTIES OF MERCHANTABILITY, AND FITNESS OR PURPOSE., ARE
LIMITED IN DURATION FOR ONE YEAR FROM THE DATE OF PURCHASE O THE FRAME ONLY AND 90 DAYS FOR ALL OTHER PARTS, EXEPT TIRES AND TUBES WHICH ARE NOT
WARRANTED. WORKSMAN TRADING CORPORATION IS THE MANUFACTURER. MISUSE OF THE CYCLES INCLUDING OFF ROAD RIDING, INSTALLATION OF MOTORS OR POWER
ASSISTS, ALTERATIONS, REPAIRS USING PARTS OTHER THAN GENUINE WORKSMAN CYCLE PARTS VOIDS WARRANTY. WORKSMAN TRADING CORPORATION IS NOT RESPONSIBLE
FOR MAINTAINING RECORDS OF SERIAL NUMBERS. VOID WHERE PROHIBITED BY STATE LAW.
FAX THIS COMPLETED REGISTRATION FORM TO 718-529-4803 OR MAIL
WORKSMAN CYCLES: 94-15 100
TH
ST OZONE PARK NY 11416
Name of Purchaser________________________________
Company Name___________________________________
Mailing Address______________________________________________________________________________________
Tel__________________________ Fax __________________________e-mail ___________________________________
Date of Purchase__________________________ Dealer name________________________________________________
Address of Dealer_____________________________________________________________________________________
Serial Number (located under crank housing)_________________________ Color_______________________
NOTES____________________________________________________________________________________________________
SIGNATURE
_____________________________________________
DATE______________________________
