123
360 C
OASTAL
•
Install the drain plug in the hull.
•
Charge and install the batteries.
•
Check the engines for damage and follow the
manufacturer’s instructions for recommissioning.
•
Check the engine mounting bolts to make sure they are
tight.
•
Perform all routine maintenance.
•
Check all hose clamps and make sure they are tight and
not corroded.
•
Pump the antifreeze from the fresh and raw water systems
and flush several times with fresh water. Make sure all
antifreeze is flushed from the water heater and it is filled
with fresh water before it is activated.
•
Check and lubricate the steering system.
•
Clean and wash the boat.
•
Install all upholstery, cushions and canvas.
After Launching:
•
Carefully check the engines and all water systems for
leaks. Operate each system one at a time checking for
leaks and proper operation.
•
Check the bilge pump manual and automatic switches.
•
Check the propeller shaft couplings for proper alignment.
Allow the boat to remain in the water for several hours
before checking the alignment.
•
Prime the fuel system and start the engines. When each
engine starts, check the exhaust ports for water flow. This
insures that the cooling pump is operating.
•
Carefully monitor the gauges and check for leakage and
abnormal noises.
•
Operate the boat at slow speeds until the engine
temperature stabilizes and all systems are operating
normally.
•
Start the generator and monitor the exhaust port for a
steady stream of water. It may take 20 or 30 seconds for
the muffler to fill and for water to appear at the port.
This ensures that the cooling pump is operating. Carefully
inspect the generator and all hoses for leaks, paying
particular attention to the muffler and exhaust hoses. Any
leak, no matter how minor must be corrected immediately.
MAKE SURE THE GENERATOR MUFFLER OR
EXHAUST SYSTEM HAS NOT BEEN DAMAGED
DURING WINTER STORAGE AND THAT THE DRAIN
PLUGS ARE INSTALLED AND PROPERLY
TIGHTENED. LOOSE OR MISSING DRAIN PLUGS
AND A DAMAGED OR LEAKING MUFFLER OR
EXHAUST HOSES WILL ALLOW CARBON
MONOXIDE, ENGINE GASES, AND WATER INTO THE
BILGE CREATING A POTENTIALLY HAZARDOUS
CONDITION.
Summary of Contents for 360 Coastal
