62
Neutra-Salt System
NOTE! Check all local and regional regulations when dis-
charging any chemical into the water. Some areas
may prohibit the discharge of Neutra-Salt into the
water.
The Neutra-Salt system is only intended for use in engines
that operate in salt or brackish water. It is not intended for
engines used in fresh water.
If the engine is equipped with a Neutra-Salt system:
Caution!
The Neutra-Salt solution is not an antifreeze solution and
will freeze. If freezing conditions are possible, drain the
engine after the procedure is complete. The solution
will continue to provide corrosion protection for the en-
gine after it is drained. Consult the Maintenance Sec-
tion for proper engine draining procedures. For winter
storage of the Neutra-Salt system, completely drain the
system. Loosen the hose clamps on the inlet side of the
solenoid and at the nipple on the back of the engine.
Drain the concentrate and then reinstall the hoses and
clamps. If freezing conditions are possible and the boat
is still being used, make sure the reservoir is no more
that 75% full.
FIRST AID!
Neutra-Salt concentrate may cause eye irritation. In case
of contact, flush eyes thoroughly with water for at least
15 minutes. If irritation persists, get medical attention.
System Operation
1. When injected in to the engine’s cooling system the
Neutra-Salt solution will flush salt deposits and leave a
corrosion inhibiting coating on all metal parts.
2. The Neutra-Salt system should be used at the end of
each boating day.
3. The Neutra-Salt concentrate is stored in a reservoir, usu-
ally located near the rear of the engine.
4. The concentrate is pulled from the reservoir and in to
the cooling system by the engine’s sea water pump.
5. The concentrate only flows from the reservoir when the
solenoid is opened by pushing the rocker switch. The
solenoid is usually located very close to the reservoir.
6. The rocker switch is located at the helm.
NOTE! Some boats may have a switch that looks different
than the one shown.
1. Make sure the reservoir is at least 25% full with concen-
trate. If needed add more concentrate.
Refill only with QL Neutra-Salt Motor Flushing concentrate,
available in gallon (P/N 41103102) or quart (P/N 41103103)
bottles.
Cution!
Do not run the system with an empty reservoir. This
could damage the sea water pump which could lead to
engine damage.
Summary of Contents for 4.3OSi-C
Page 2: ......
Page 76: ...77442238 English 07 2002 ...