Volvo Penta 3.0 GS, Operator'S Manual

Page: 57 / 96

57
Preparing for boating after storage (“summerization”) _____________________________
1. Replace all drain plugs.
2. Replace rubber caps and clamps or plugs.
3. Connect hoses and check their condition; tighten clamps and connections.
4. Install boat drain plug, if removed.
5. Remove distributor cap and rotor.
6. Wipe inside of distributor cap dry with a clean cloth; spray with Volvo Penta anti-corrosion spray.
7. Replace rotor and distributor cap.
8. Clean battery terminals and check battery charge.
9. With ignition switch in OFF position, install battery and attach battery cables.
10.Spray terminals with Volvo Penta anti-corrosion spray.
11. Open the fuel shut-off valve and check all fuel line connections for leaks.
12.Check the flame arrestor and clean if necessary.
13.Make a thorough check of boat and engine for loose or missing nuts and screws.
14.Pump the bilge dry and air out engine compartment. Federal, state, and/or local regulations prohibit the
pumping of oil into any navigable waters.
15.Check all reservoir oil levels and fill as necessary.
16.Check drive and transom shield anodes. Clean or replace as necessary.
Off-season storage preparations (“winterization”) _________________________________
Be sure to properly winterize your Volvo Penta equipment. Engine or drive damage can result from ignoring simple
preventive maintenance steps during autumn. Winterizing gives you the assurance that your engine will run more
reliably and economically in the springtime.
Volvo Penta recommends that you have your Volvo Penta dealer “winterize” your engine and drive. Your dealer will
provide the proper servicing and maintenance to ensure that your equipment is treated and stored properly.
Exhaust system ______________________________________________________________
Engine exhaust system
Periodically inspect the engine exhaust system. Check for
•
Deteriorated hoses
•
Burned hoses
•
Loose clamps
•
Evidence of water leaks
•
Corrosion or blockage in the exhaust manifold and riser
Replace damaged or defective components, and securely
tighten all clamps. Any exhaust leak must be repaired
before you operate your boat. Exhaust leaks release fumes
that can create hazardous conditions for operator and
passengers.
7797286 - Downloaded from www.volvopenta.com 19/05/2015 19:28:09