3
2
1. SAFETY INFORMATION AND INSTRUCTIONS
1.1
SAFETY SYMBOLS
The following symbols will be used throughout this manual.
The following safety precautions must be followed at all times along with any
additional existing safety rules.
1.2 CHARGING INSTRUCTIONS
For best results, charge the battery in temperatures ranging from 65 degrees F
(18 degrees C) to 75 degrees F (24 degrees C). Inflator must be charged at least
24 hours using the 120 volt AC method prior to initial use.
A. INITIAL USE
The Vector Compressor/Inflator is shipped in a partially charged state (not fully
charged). The battery must be charged using the 120 volt AC method before
the initial use.
B. END OF USE/RECHARGE
When charge indicator runs down, recharge product before storing away,
using the 120 volt AC method.
C. MAINTENANCE/RECHARGE/STORED ITEM
Recharge the unit every 3 to 6 months even if the unit has not been used.
D. GENERAL SAFETY PRECAUTIONS
1.
Completely read this product manual as well as all interactive applicable
manufacturers’ and/or vehicles’ manuals and safety guidelines.
2.
Be familiar with the proper use of the unit and all interactive applicable
manufacturers’ products.
3.
Never exceed recommended pressures or over inflate tires/inflatable
items. Bursting articles can cause serious injury. Always check pressure
with the pressure gauge. It is recommended to wear protective eyewear
when inflating tires/inflatable items.
4.
Always wear protective clothing (i.e. no vinyl) and eyewear when using
INDICATES AN IMMINENTLY HAZARDOUS SITUATION
WHICH, IF NOT AVOIDED, WILL RESULT IN DEATH OR
SERIOUS INJURY.
INDICATES A POTENTIALLY HAZARDOUS SITUATION
WHICH, IF NOT AVOIDED, COULD RESULT IN DEATH OR
SERIOUS INJURY.
Indicates a hazardous situation which, if not avoided, MAY
result in minor or moderate injury.
Indicates important information that, if not followed, may
cause damage to equipment.
TABLE OF CONTENTS
1. SAFETY INFORMATION AND INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . .3
1.1. Safety Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
1.2. Charging Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
A. Initial Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
B. End of use/Recharge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
C. Maintenance/Recharge/Stored Item . . . . . . . . . . . . . . . . . . . .3
D. General Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . .3
2. INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
3. OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
3.1. 120 Volt AC Recharging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
3.2. 12 Volt DC/DC Recharging . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
3.3. Battery Indicator Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
4. COMPRESSOR/INFLATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
4.1. Tire Inflation or Products With A Valve Stem . . . . . . . . . . . . . . . . .9
4.2. Other Inflatables Without Valve Stem . . . . . . . . . . . . . . . . . . . . .10
4.3. Typical Inflation Times For Products Without Valve Stems . . . . . . .10
5. 12 VOLT PORTABLE POWER SOURCE . . . . . . . . . . . . . . . . . . . . . . . .11
5.1. Estimated 12 Volt DC Usage Times . . . . . . . . . . . . . . . . . . . . . . .11
6. LANTERN/SPOT LIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
7. REPLACEMENT PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
7.1. Spotlight Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
7.2. Fluorescent Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . .12
7.3. Battery Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
7.4. Battery Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
8. FUSE REPLACEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
9. SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
