52
52
Front Wheel
Front Wheel
（
（
1
1
）
）
Place lift truck on
Place lift truck on level concrete.
level concrete.
（
（
2
2
）
）
Start engine and raise carriage about 100mm
Start engine and raise carriage about 100mm
height.
height.
（
（
3
3
）
）
Place chocks behind rear wheels to prevent
Place chocks behind rear wheels to prevent
movement of forklift.
movement of forklift.
（
（
4
4
）
）
Loosen wheel nuts 1
Loosen wheel nuts 1
--
2 turns each by turning
2 turns each by turning
them counter
them counter
--
clockwise.
clockwise.
（
（
5
5
）
）
Tilt mast fully backward, and place a wooden
Tilt mast fully backward, and place a wooden
block under each side of outer mast.
block under each side of outer mast.
（
（
6
6
）
）
Tilt mast forward until front tires are raised
Tilt mast forward until front tires are raised
from surface.
from surface.
!! C
Ca
au
uttiio
on
n
：
：
Do not allow loose nuts before the front
Do not allow loose nuts before the front
wheels leave the ground.
wheels leave the ground.
（
（
7
7
）
）
Support forklift truck by putting additional
Support forklift truck by putting additional
wooden blocks under each side of the front
wooden blocks under each side of the front
--
end frame
end frame
as shown below. Stop the engine.
as shown below. Stop the engine.
（
（
8
8
）
）
Take out the wheel nuts and replace the front
Take out the wheel nuts and replace the front
wheel tire.
wheel tire.
!! W
Wa
arrn
niin
ng
g
：
：
a. When removing tire from wheel rim, do not
a. When removing tire from wheel rim, do not
remove rim set bolts and nuts before
remove rim set bolts and nuts before
releasing air. (Pneumatic)
releasing air. (Pneumatic)
b. Make sure that wooden blocks used to
b. Make sure that wooden blocks used to
support lift truck are solid, one
support lift truck are solid, one
--
piece units.
piece units.
c. Never get under forklift while it is supported
c. Never get under forklift while it is supported
only by wooden blocks.
only by wooden blocks.
https://www.forkliftpdfmanuals.com/
Summary of Contents for UT25C
Page 85: ...79 79 10 Labels 10 Labels https www forkliftpdfmanuals com ...
Page 90: ...84 84 7 7 Tip Over Warning Label Tip Over Warning Label https www forkliftpdfmanuals com ...
Page 119: ...113 113 https www forkliftpdfmanuals com ...
Page 139: ...133 133 IMPCO Single Fuel System IMPCO Single Fuel System https www forkliftpdfmanuals com ...
