Tru-Turf R52-11T, Manual

Page: 13 / 44

TRU-TURF R52-11T Golf Greens Roller Manual 11
• If bearings are faulty
(a) Remove the complete smoothing head from the
machine, undo the four swivel mount bolts on
upper body and steering rod, wheel the roller away
until the total head is exposed to work on.
(b) Remove roller shaft bolts from end plates, remove
rollers from the heads.
(c) Screw a bolt back into the shaft end, knock out one
end bearing, then use the same shaft to knock out
the other end bearing.
(d) Fit new bearings, replace rollers into the heads,
lubricate shaft bolts with an anti seize compound
before installing them. Tighten securely and ensure
rollers rotate freely when fully tightened.
(e) Be sure the spacing washers are fi tted to the shaft
ends before installing the rollers into the heads, in
the correct sequence smaller diameter washer fi rst
and the larger diameter washer last.
(f) Sometimes, if the rollers do not rotate freely when
installed use a soft headed hammer to hit the
securing bolts on each end of the head, this will seat
all parts and allow the roller to rotate freely.
(g) If the rods are removed or lengths altered ensure
they are correctly adjusted so that the three heads
are parallel to each other when in the straight
ahead position. Adjust if necessary.
Changing engine oil
• Change oil and service as per the manufacturers
Servicing Schedule enclosed as a separate insert to
this manual.
Description Pre-Delivery Pre-Operating 12 Monthly
Check Engine oil
√ √
Check Transmission Oil Level
√ √
Beware of contaminants entering the transmission √ √
Lubricate drive chain with WD40 or equivalent
√ √
Check Tires Max 18 P.S.I.
√ √
Check Gas
√ √
Check Smoothing Roller Bearing
√ √
Check Drive Roller Bearings
√ √
Check for loose Nuts and Bolts √ √
Renew Engine Oil as per manufacturers Handbook
Renew Transmission Oil - See page 1 for correct oil every 500hrs or...
√
Renew Transmission Oil Filter
* √
Renew Smoothing Roller Bearings * √
Renew Drive Roller Bearings
* √
Renew Chain Tensioner Sprocket Bearings
* √
Renew Drive Chain
* √
Replace Foot Pedal Struts *
Replace Trailer Strut
*
Changing transmission oil
• See page 12 and 14.
Ongoing Maintenance, Lubricant and Replacement
Schedule (below)
Note. Areas indicated with a * need to be changed
when defective or as required. This may be before the
recommended replacement schedule. Please replace all
parts as necessary.
Maintenance