TCE Group S.r.l.
Installation, use and maintenance manual
–
Serie NEOS
22
Charging stations with less than 4% of hydrogen in the air are considered safe against explosions caused by this gas.
Good ventilation ensures a safe and reliable working environment for charging operations.
During charging, TCE Group S.r.l. recommends keeping a distance of AT LEAST 120cm between the battery charger
and the battery and keeping at a safe distance any object that could cause or be a source of sparks or flame.
To avoid problems or damage caused by gas, steam or acid, TCE Group S.r.l. recommends:
-
Do not disconnect the charging plug while charging
-
Do not breathe the gas or vapor released by the battery during charging
-
Make sure that the battery is in a well-ventilated area when charging
-
Avoid and prevent short circuit in battery
-
Do not place any tools on top of the battery while charging
While the device is in operation, it is recommended that all unauthorized personnel is kept away from the charger. In case of
people near the device during a charging cycle, TCE Group S.r.l. recommends:
-
Warn them about the various dangers caused by the device in operation (gas, dangers of electrocution and charging
currents, electromagnetic fields, etc. etc.)
-
Provide immediately personal protective equipment (ex. Gloves, protective helmets, etc. etc.)
-
Try to avoid direct contact between the device and unauthorized personnel
Use procedures
•
Once the battery is connected to the charger, if the battery voltage is within a predetermined range, charging will start
automatically
•
The front LED light will flash RED to indicate that the battery is connected and the battery charge status is below 80%.
Above 80% the YELLOW light will start flashing. Upon reaching 100% the GREEN light will start flashing and it will be
possible to disconnect the device from the battery
•
When the battery is fully charged, the charging process will be automatically interrupted
•
In case of values outside the preset range or if the device reaches the completion of the safety timer, the charge will be
automatically interrupted
•
In the event of a blackout during the charging phase, the charger will automatically resume the cycle when the blackout
is over
