R&E Stricker Reha-Entwicklungen GmbH
3
Additional operating instructions Lipo Smart
Safety and driving instructions for accident prevention
NOTE
Observe all safety and hazard information and
instructions, both in this and in all other operating
instructions supplied.
5.1 Safety instructions for battery
and charger
WARNING
Before performing any repair, cleaning or
maintenance tasks on the handbike, switch off the
electrical components and remove the batteries
from the handbike.
The batteries supplied are used exclusively to
operate the drive systems of the handbike. Do not
connect any other systems to the battery. Any use
beyond this requires the written approval of the
manufacturer. All information is state of the art at
the time of printing. Cases of misuse include:
• Use of the battery contrary to the description
and instructions in the user manual.
• Use of the battery in excess of the technical
performance limits
•
Technical modification of the battery
•
Modification of the battery software
• Use of the battery to supply other systems
We accept no liability for damage in the event of
misuse.
HEALTH INFORMATION
In case of contact with leaking gases, supply
fresh air. In case of body contact with battery
fluids, rinse the affected body part with plenty
of water. In case of contact with mucous
membranes or discomfort, consult a physician.
5.1.1 Operation
Make sure that the batteries are firmly seated in
the holders provided and lock the batteries. This
applies especially if you have previously removed
the batteries from the power assist device for
charging.
Observe the battery temperature on the display
during extreme uphill travel. The temperature must
not exceed 45 °C. To prevent overheating, take an
operating break to relieve the batteries.
Only operate the battery in ambient temperatures
between -20 °C and 50 °C. Operation outside the
temperature range shortens the service life of the
battery and poses a risk of ignition.
Do not subject the battery to shocks. If the battery
has been dropped or has taken a knock, the battery
must be checked by the manufacturer. Contact
your dealer or the manufacturer for return and
repair/disposal procedures. This also applies to
otherwise damaged or defective batteries. Never
continue to use a damaged or defective battery. Do
not open the battery yourself.
Keep the battery dry and clean. Protect the battery
against the ingress of moisture or foreign particles.
Do not connect the battery‘s contacts to metallic
or other conductive objects. Keep the battery away
from small metallic objects such as screws, coins,
paper clips, keys or similar to avoid a short circuit.
Clean dirty contacts with a dry, clean cloth only. Do
not immerse the battery in water.
If you notice that the battery is overheating, leaking,
smoking, emitting an unusual odour or deforming,
stop using the battery immediately and switch it
off.
Protect the battery from heat and open fire
(radiators, microwaves, ovens, strong sunlight).
Exposure to heat can cause ignition and explosion.
Do not open the battery casing. Do not
disassemble the battery. Damage to the battery
cells or contact with oxygen can cause fire and
explosion. Opening the battery will void the
warranty.
FIRE FIGHTING
Do not attempt to extinguish lithium-ion
batteries with water or other liquids in the event
of a fire. Sand is recommended by battery cell
manufacturers as the only extinguishing agent.
There is a risk of explosion in the event of a fire.
Extinguish lead-gel batteries with water, foam or
CO
2
. Dangerous gases may be formed in a fire
involving lead-gel batteries. Do not breathe in the
gases under any circumstances.
5.1.2 Charging process
WARNING
Do not leave the battery unattended during the
charging process.
