Wiring the SB6000U
Wiring the AC Output
5-6
SMA America
SB6000U-13:SE2506
Connecting the AC Wires
Use the following procedure to connect the AC wires to the SB6000U:
WARNING: You must connect the wires that carry the AC
voltage from the SB6000U to the utility grid in the order
described in this procedure. Deviating from this procedure
could expose you to lethal voltages that can cause serious
injury and/or death.
1. Turn OFF the main breaker in the main utility breaker box.
2. Remove interior breaker panel cover.
3. If you are replacing an existing inverter, disconnect the wires for the AC line you
are working with in the breaker box.
4. Install a
3/4
-inch conduit fitting in the SB6000U’s AC wiring knockout (the
knockout on the right side of the SB6000U, as shown in Figure 5-1). Fasten the
conduit fitting on the inside of the SB6000U with the appropriate locknut.
5. Install
3/4
-inch conduit between the main breaker box and the SB6000U’s AC
wiring knockout.
6. Pull the AC wires through the conduit from the interior of the breaker box to the
interior of the SB6000U.
Note:
Refer to Figure 5-4 on page 5-7 for steps 7 through 10.
CAUTION: Avoid using wire nuts to join any wires together or
to make any connections anywhere in the PV system. Wire nuts
are a frequent cause of unreliable, resistive connections, and
ground faults.
7. Connect the AC equipment-ground wire to the terminal labeled PE in the
SB6000U.
8. For 208/240/277 V connect the L1 (AC line 1or HOT) wire to the terminal labeled
L1 in the SB6000U.
9. For 208/240 V connect the L2 (AC line 2) and N (AC line N) wire to the terminal
labeled L2 and N in the SB6000U. For 277 V connect the N (AC line N) wire to the
terminal labeled N in the SB6000U. NOTE: For 277 V the L2 terminal is not used.
10. Connect the wires and tighten to a torque of 18 in-lb.
11. Verify that all connections are correctly wired and properly torqued.
http://www.wholesalesolar.com/inverters.html
http://www.wholesalesolar.com/inverters.html
Summary of Contents for Sunny Boy 6000
Page 2: ...http www wholesalesolar com inverters html http www wholesalesolar com inverters html ...
Page 89: ...http www wholesalesolar com inverters html http www wholesalesolar com inverters html ...
Page 90: ...http www wholesalesolar com inverters html http www wholesalesolar com inverters html ...
