Page 24 of 28
P/N 595277-01 Rev E 10/17
CHECK YOUR WORK!
BEFORE ASSEMBLY OF BATTERY COVER,
CHECK TO SEE ALL BATTERIES ARE FRESH,
NEW BATTERIES OF THE TYPE INDICATED
ABOVE AND THAT THEY HAVE BEEN INSTALLED
PROPERLY.
FIGURE 7
BE SURE SEALING
SURFACES ARE CLEAN
BEFORE REASSEMBLY
6. The battery cover must be installed so that it is water tight after replace-
ment. Clean the sealing rib around battery compartment and sealing face
of the cover, shown in FIGURE 7, by wiping with a clean damp cloth to
remove any dirt or foreign matter which might prevent a proper seal. Check
cover gasket for tears or cuts. If damage is found, remove respirator from
service and tag for repair by authorized personnel.
7. To install battery cover, align the three grooves on the cover with the three
tabs on the battery compartment and tighten the cover screw. The cover
must be water tight to prevent damage to the equipment.
8. To test the batteries, verify that the PAK-ALERT distress alarm is in the off
condition (cylinder valve closed with no flashing green LED on the control
console).
a) Press and hold the reset button on the console. A GREEN light on the
console indicates sufficient battery power and that the batteries are
properly installed.
b) If the unit displays the LOW BATTERY condition or no light at all, verify
that the batteries are properly installed. If the batteries were properly
installed, remove the batteries and replace with a new set of six (6)
batteries.
c) If another set of properly installed batteries will still not produce a
GREEN light on the battery test, remove the unit from service and mark
for repair by authorized personnel.
AFTER REPLACEMENT OF BATTERIES, PERFORM A REGULAR
OPERATIONAL INSPECTION BEFORE RETURNING RESPIRATOR TO
SERVICE.
CAUTION
IMPROPER BATTERY COVER INSTALLATION
CAN CAUSE BATTERIES TO OVERHEAT AND
MAY CAUSE DAMAGE TO THE PRODUCT.
ALWAYS MAKE SURE THAT THE ALIGNMENT
GROOVES ON THE BATTERY COVER ARE
ALIGNED WITH THE TABS ON THE BATTERY
COMPARTMENT DURING INSTALLATION OF
THE COVER.
DRAFT
NOT
FOR
DISTRIBUTION
Summary of Contents for PAK-ALERT
Page 2: ...Page 2 of 28 P N 595277 01 Rev E 10 17 D R A F T N O T F O R D I S T R I B U T I O N ...
Page 4: ...Page 4 of 28 P N 595277 01 Rev E 10 17 D R A F T N O T F O R D I S T R I B U T I O N ...
Page 26: ...Page 26 of 28 P N 595277 01 Rev E 10 17 NOTES D R A F T N O T F O R D I S T R I B U T I O N ...
Page 27: ...Page 27 of 28 P N 595277 01 Rev E 10 17 NOTES D R A F T N O T F O R D I S T R I B U T I O N ...
